11-15-2007, 05:33 PM | #1 |
Not Yet Wild
Join Date: Nov 2007
Posts: 25
|
need help with Melex resistor
I bought an old Melex off ebay, model 252. Have no idea what year it is, but I'm thinking it needs a new resistor set because I changed out the solenoid and ignition key switch, and the batteries seem good. They are not fully charged up but when I try to run the cart (it's jacked up with the 2 rear wheels off the ground) with the cart plugged in to the charger, the motor shaft spins slowly with the pedal to the metal and the rear wheels barely move. The motor is brand new and I know it's not that. Question is, what year is a 252? And I came across a resistor pack on ebay that says for EZ-go 1984 and older models, and looks like it could work since I know Melex is an ezgo knock off brand. Would that work? And if so, is the resistor pack just a 2 wire connection when I get it because it looks like 2 short battery cables go to it, but mine is so old and corroded I don't know how it is supposed to be wired properly. Thanks for any help
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-16-2007, 08:23 AM | #2 |
Just me. .
Join Date: Sep 2007
Location: Pensacola, FL
Posts: 1,092
|
Re: need help with Melex resistor
check f/r switch, then check the wiper board assembly..
The resistor should have about 5 wires going from it to the wiper board, the pedal is connected to the wiper board connecting to each copper contact controlling speed... other problems... a battery totally failing and causing the car to die... motor brushes worn, amature worn... Any motor wire burnt and almost broken... |
11-20-2007, 06:53 PM | #3 |
WILD
Join Date: May 2007
Location: lebanon county,pa
Posts: 1,266
|
Re: need help with Melex resistor
At full speed the resistors are out of circuit, sounds like it isnt wired up right, or contacts are shot,or cables.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
resistor cart | Electric Club Car | |||
Melex 3 wheeler conversion. | Gas Melex | |||
I want to put air ride on a melex | On Road Golf Carts! | |||
Red Hot Resistor Coil | Electric EZGO | |||
Need Help with Melex | Melex |