|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
06-12-2017, 11:31 PM | #1 |
Not Yet Wild
Join Date: Jun 2017
Posts: 1
|
G2A - Bypassing the Voltage Regulator
I've inherited a '91 4-seater G2A... It was frying batteries apparently, and I measured 18VDC on run-abouts, so I've replace the Voltage Regulator (VR). I'm now seeing between 13VDC and 16.7VDC, which is still concerning me.
Trying to reason out this high voltage on a new VR, I'm wondering if there's a grounding issue some where. I need to go clean all the contacts! But it also occurred to me that perhaps I could bypass the VR connection to the battery. I would do this by adding a rectifier to block current to the battery from the generator, while charging the battery via a more sophisticated battery charger that could handle the higher input voltage: Either a DC-DC battery charger, or a Inverter->AC Battery charger: This part of the circuit would be blocked from taking current from the batteries and would run from the generator only. For a little context, ultimately, I'm going to add a couple of 6VDC deep cycle batteries in series to drive a large stereo system when stationary. I would isolate these batteries in the same way, but allow the stereo to draw from the generator while the engine was running. Ideas and insight would be appreciated! Thanks in advance, T |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-13-2017, 06:57 AM | #2 |
Gone Wild
Join Date: May 2011
Location: Pittsburgh
Posts: 2,953
|
Re: G2A - Bypassing the Voltage Regulator
13 - 16v sounds about about right, actually. The way I test is to jack the back of the cart up, get the thing revving at about 1/2 speed then measure voltage. I like to have right around 14v at that point. Really, 14v would represent the average voltage going back to the battery. It would be more like 13v or so at slower speeds and probably 15v or so at higher speeds. Your top end may be just a bit high but not as much as you think. Given how the currents average out you are probably ok.
|
Tags |
battery, charging, voltage regulator, yamaha g2 |
|
|
Similar Threads | ||||
Thread | Forum | |||
Voltage Regulator??? | Gas EZGO | |||
Voltage regulator | Gas Yamaha | |||
G9 voltage regulator | Gas Yamaha | |||
Voltage Regulator | Electric Club Car | |||
G1 voltage regulator | Gas Yamaha |