Club Car DS 2000 Wont Start

[David Qualls]

Engine turns over strong but will not start...spray carb cleaner in carburetor starts right up...Thoughts? Thx..

[Scooter Bob]

Since it runs on carb cleaner, then you probably have a fuel supply problem.

The easy first step is to remove the fuel line between the pump and the carb and spin the starter to verify you are pumping fuel.

If you are not pumping fuel properly, then you need to be looking at the fuel pump and filters or possibly plugged lines.

If you are pumping fuel good, then you have carb issues. Could be the float needle stuck shut, or other jets or orfices plugged.

Has it been sitting over winter, or did this problem just arrise after running just fine?

[Bassdeer]

Originally Posted by Scooter Bob

Since it runs on carb cleaner, then you probably have a fuel supply problem.

The easy first step is to remove the fuel line between the pump and the carb and spin the starter to verify you are pumping fuel.

If you are not pumping fuel properly, then you need to be looking at the fuel pump and filters or possibly plugged lines.

If you are pumping fuel good, then you have carb issues. Could be the float needle stuck shut, or other jets or orfices plugged.

Has it been sitting over winter, or did this problem just arrise after running just fine?

Bob's right, start with this in order.

[David Qualls]

Replaced fuel filters..fuel pump working fine..Thx Bob...running great now..