lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 08-18-2012, 02:37 PM   #1
brent44j
Not Yet Wild
Yamaha
 
Join Date: Nov 2011
Location: Loganville Ga
Posts: 13
Default G14 bad engine vibration

I rebuilt my G14 engine about 4 months ago and the engine ran fine. I was going down a hill wide open throttle and got a bad vibration in the engine. Also the drive belt flipped due the excessive vibration. I remembered lining all the dots correctly while putting the camshaft and balancer back in. Any ideas?
brent44j is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 08-19-2012, 05:03 PM   #2
brent44j
Not Yet Wild
Yamaha
 
Join Date: Nov 2011
Location: Loganville Ga
Posts: 13
Default Re: G14 bad engine vibration

This is what I found out, the belt slung off and bent the rear belt pulley. I straightened that and the vibration is gone. Now I noticed that the rear end has a roaring noise with a slight vibration on deceleration. The gear oil looks clean and spins smoothly while rotating by hand. Any thoughts???
brent44j is offline   Reply With Quote
Old 08-23-2012, 08:29 AM   #3
Ray and Lori's g14
Gone Wild
 
Ray and Lori's g14's Avatar
Club Car
 
Join Date: May 2010
Location: Houston, TX
Posts: 203
Default Re: G14 bad engine vibration

Check the sliding sheave in the driven clutch on the rear end. I have had the same sound and also the vibration that fixed it in my case
Ray and Lori's g14 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
vibration at certain rpm Gas EZGO
Front end vibration Electric EZGO
85 G1 Vibration Gas Yamaha
vibration Gas Columbia ParCar
91 Par Car Excessive Vibration Gas Columbia ParCar


All times are GMT -5. The time now is 12:32 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.