|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
11-04-2018, 06:04 PM | #11 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,234
|
Re: yikes 1st time fixing rxv
No you don't need to save the handle there not used anymore.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-04-2018, 07:43 PM | #12 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: yikes 1st time fixing rxv
Use the lowest range of resistance on your meter to measure the motor brake coil resistance. You are looking for 25.5 ohms nominal. Below 20 ohms is too low and above 30 ohms is too high. The coil heats up in operation and tends to vary outside of the normal range, then fails.
|
11-05-2018, 09:12 AM | #13 |
Getting Wild
Join Date: Sep 2014
Posts: 76
|
Re: yikes 1st time fixing rxv
25.8 ohms 1st thing in the morning i will replug 48 volt feed to motor brake and see what happens........ AS I SAID ,,,,, very intermittent.
cart runs fine...... could drag or lockup anytime...... |
11-05-2018, 07:37 PM | #14 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: yikes 1st time fixing rxv
25.8 ohms is very very good, real close to the spec... Intermittent motor brake issues could be corrosion in the harness at the splices, or battery voltage dropping too low, affecting motor brake voltage/current.
|
11-06-2018, 12:23 AM | #15 |
Getting Wild
Join Date: Sep 2014
Posts: 76
|
Re: yikes 1st time fixing rxv
could these symptoms just be the very 1st signs of a motorbrake on its
way to failure? also...... what does that lever actually do?? |
|
|
Similar Threads | ||||
Thread | Forum | |||
Fixing up G16 | Gas Yamaha | |||
Fixing up a 1996 CC DS 48v | Electric Club Car | |||
fixing up my cart | Electric EZGO | |||
Fixing a rip in fender | Gas EZGO | |||
93 is it worth fixing? | Electric EZGO |