|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-13-2018, 12:56 PM | #1 |
Not Yet Wild
Join Date: Dec 2018
Posts: 26
|
EZGO controller issue
I have a 36v golf cart that won't move. Im not sure what year, unable to find any ID info any where. I have replaced the pedal micro switch and now the solenoid just clicks when the pedal is pressed. Does not have a tow/maint switch. I have 37.3 volts at battery pack and at battery side of solenoid. Not sure where to go from here. Believe I may have burnt up the controller, but can't find any info on testing it (Curtis PMC - PN 25864G09). Any assistance would be appreciated. Thanks, Terry.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-13-2018, 01:04 PM | #2 |
Not Yet Wild
Join Date: May 2017
Location: Carlisle, PA
Posts: 47
|
Re: EZGO controller issue
You can try the link below for some troubleshooting tips, it may help.
http://www.fsip.biz/Documents/E-Z-GO...04-Control.pdf |
12-13-2018, 02:28 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: EZGO controller issue
If there is a pre-charge resistor on the solenoid big posts remove one side.
Then test for 36 volts on the battery side big post of the solenoid with the pedal up and 36v on both big posts when the the solenoid clicks if yes the solenoid is working. Proceed to the controller. There should be power to the red small wire when the solenoid clicks |
12-13-2018, 05:17 PM | #4 |
Not Yet Wild
Join Date: Dec 2018
Posts: 26
|
Re: EZGO controller issue
Thanks Jeremy98 for the link. All tests were good except pin 1 voltage check had no volts detected. Said replace ITS, just replaced micro switch is it common for both to go bad at same time?
|
12-13-2018, 05:21 PM | #5 | |
Not Yet Wild
Join Date: Dec 2018
Posts: 26
|
Re: EZGO controller issue
Quote:
|
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EZGO TXT - Controller - Undervoltage issue? | Electric EZGO | |||
Ezgo controller issue | Electric EZGO | |||
2006 EZGO TXT PDS 36V - ITS v reading issue -Controller bad? | Electric EZGO | |||
ezgo series cart controller issue | Electric EZGO | |||
EZGO 36 volt controller wiring issue | Electric EZGO |