97 Ezgo Motor runs but will not move

ram101a · 05-23-2009, 02:33 PM

Hi all,

I have a '97 Ezgo that just stopped going today! My son was putting around the yard and it just stopped moving. It had done this once before and cooled down and started running again but, this time it won't go!
The motor runs but the belt will not engage to turn the wheels. I am not up on all the names of the parts but if it is a simple or relitively simple fix I will give it a try. Otherwise I might be off to the rapair man!!

I have tried forward and reverse and still the same problem also let it sit for a few hours to cool. I checked all the wires and cables for breaks. I tried searching for a simular problem but the ones I found did not seem to fit! Any ideas would be great thanks in advance!

ruredy · 05-23-2009, 02:37 PM

does the engine run and rev up, or is it just being turned over by the starter?

ram101a · 05-23-2009, 02:43 PM

Wow that was quick!!

I just lifted the back end up to see if it would turn the wheels and after doing this I think it is just the srarter turning it over and not the motor runining. When I pressthe gas everything turns except the wheels. I pulled the fuel filter and after putting back on it does not seem to pull gas from the tank into the filter.

ruredy · 05-23-2009, 02:52 PM

Does it have gas in it?

ram101a · 05-23-2009, 02:54 PM

Quote:

Originally Posted by ruredy

Does it have gas in it?

Yes 1/2 tank. I updated my last post to say that the fuel filter does not seem to be pulling gas into it. I had pulled it to check the lines for blockages and when I put it back on it will not suck gas!

ruredy · 05-23-2009, 02:57 PM

look in the tank and see if the pick up tube has come off... happens some times...

ram101a · 05-23-2009, 03:02 PM

OK. I pulled all the hoses from the tank and I do not know its name but it is on the wall with three hoses on it. one left that goes to the carb one right that goes to gas tank and a bottom one that not sure where it goes. I pulled them all off, if the left one is pulled off and I try to run it it spits gas and pulls it through the fuel filter. If I put it back on it stops. Does this mean the carb is clogged or bad maybe? The bottom one has good suction.

ruredy · 05-23-2009, 03:14 PM

If it was running right before this then the carb probably good, maybe it's just filled with gas and the float has shut off incoming gas.
You need to check and see if you have spark to the plugs, coils will heat up and quit working sometimes when they start going bad

ram101a · 05-23-2009, 03:16 PM

Good spark on the plugs. Just pulled both of them!

ruredy · 05-23-2009, 03:20 PM

might try tapping on the carb with something, if the float valve is sticking it may open up.
Have you ever adjusted the valves?

05-23-2009, 02:33 PM	#1
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14	97 Ezgo Motor runs but will not move Hi all, I have a '97 Ezgo that just stopped going today! My son was putting around the yard and it just stopped moving. It had done this once before and cooled down and started running again but, this time it won't go! The motor runs but the belt will not engage to turn the wheels. I am not up on all the names of the parts but if it is a simple or relitively simple fix I will give it a try. Otherwise I might be off to the rapair man!! I have tried forward and reverse and still the same problem also let it sit for a few hours to cool. I checked all the wires and cables for breaks. I tried searching for a simular problem but the ones I found did not seem to fit! Any ideas would be great thanks in advance!
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14

05-23-2009, 02:37 PM	#2
ruredy Born Wild Join Date: Mar 2007 Location: Clover SC. Posts: 5,552	Re: 97 Ezgo Motor runs but will not move does the engine run and rev up, or is it just being turned over by the starter?

05-23-2009, 02:43 PM	#3
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14	Re: 97 Ezgo Motor runs but will not move Wow that was quick!! I just lifted the back end up to see if it would turn the wheels and after doing this I think it is just the srarter turning it over and not the motor runining. When I pressthe gas everything turns except the wheels. I pulled the fuel filter and after putting back on it does not seem to pull gas from the tank into the filter.
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14

05-23-2009, 02:52 PM	#4
ruredy Born Wild Join Date: Mar 2007 Location: Clover SC. Posts: 5,552	Re: 97 Ezgo Motor runs but will not move Does it have gas in it?

05-23-2009, 02:57 PM	#6
ruredy Born Wild Join Date: Mar 2007 Location: Clover SC. Posts: 5,552	Re: 97 Ezgo Motor runs but will not move look in the tank and see if the pick up tube has come off... happens some times...

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

05-23-2009, 03:02 PM	#7
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14	Re: 97 Ezgo Motor runs but will not move OK. I pulled all the hoses from the tank and I do not know its name but it is on the wall with three hoses on it. one left that goes to the carb one right that goes to gas tank and a bottom one that not sure where it goes. I pulled them all off, if the left one is pulled off and I try to run it it spits gas and pulls it through the fuel filter. If I put it back on it stops. Does this mean the carb is clogged or bad maybe? The bottom one has good suction.
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14

05-23-2009, 03:14 PM	#8
ruredy Born Wild Join Date: Mar 2007 Location: Clover SC. Posts: 5,552	Re: 97 Ezgo Motor runs but will not move If it was running right before this then the carb probably good, maybe it's just filled with gas and the float has shut off incoming gas. You need to check and see if you have spark to the plugs, coils will heat up and quit working sometimes when they start going bad

05-23-2009, 03:16 PM	#9
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14	Re: 97 Ezgo Motor runs but will not move Good spark on the plugs. Just pulled both of them!
ram101a Not Yet Wild Join Date: Jun 2008 Posts: 14

05-23-2009, 03:20 PM	#10
ruredy Born Wild Join Date: Mar 2007 Location: Clover SC. Posts: 5,552	Re: 97 Ezgo Motor runs but will not move might try tapping on the carb with something, if the float valve is sticking it may open up. Have you ever adjusted the valves?

Similar Threads
Thread	Forum
EZGO runs in reverse, not forward	Gas EZGO
G9 motor mounts, should they move this much?	Gas Yamaha
Motor runs after I pressed the brake and a short backfire.	Gas EZGO
Club Car Complete Motor - Runs	Golf Carts and Parts
1985 Electric EZ-Go motor runs in Fwd/REV	Electric EZGO