|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-21-2019, 05:34 PM | #1 |
Not Yet Wild
Join Date: Aug 2019
Posts: 4
|
1999 TXT starts cold looses spark after 5 seconds
I can start it cold, run it about 50 ft and then it dies. let it sit for 15 mins and it does the same thing. I have done complete tune up, plugs wires, oil change, all new filters, fuel pump, took carburetor off and cleaned jets and bowl, adjusted valves, new coil, new CDI box (igniter), new pulsar coil and still problem persists. I lose spark, so I don't know if loosing spark is problem or cart dying causes cart to lose spark. Battery checks out 12.54. A blast of starter fluid in carburetor does not help start so I don't believe its fuel related. Also before this started, occasionally you would hit pedal, and nothing, completely dead, but depress pedal 4,5,6 times, then it would start and be fine, but that has stopped. She is a work cart at a driving range and we miss her dearly.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-22-2019, 11:28 AM | #2 |
Not Yet Wild
Join Date: Aug 2019
Posts: 4
|
Re: 1999 TXT starts cold looses spark after 5 seconds
somebody has suggested the starter relay may be bad??
|
08-22-2019, 11:54 AM | #3 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 1999 TXT starts cold looses spark after 5 seconds
What happens when it dies?
Does the starter continue turning? |
08-22-2019, 01:18 PM | #4 |
Not Yet Wild
Join Date: Aug 2019
Posts: 4
|
Re: 1999 TXT starts cold looses spark after 5 seconds
hey cart around thanks for the reply. yes she is trying to start shes turning over. the spark fades out when she does die
|
08-22-2019, 01:40 PM | #5 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,690
|
Re: 1999 TXT starts cold looses spark after 5 seconds
All those parts that you replaced, are the OEM or aftermarket?
Did you replace them all at the same time? Is this the reason you replaced all of those parts? Did replacing all of them make any difference at all? Have you tried running a ground strap from the negative battery terminal directly to the plate where the ignitor and everything is mounted? It's common for rust to develop between the plate and the floor, and the ignitor gets its ground through that plate. When the rust kicks in, its got a poor ground connection and causes problems like this. |
08-22-2019, 02:40 PM | #6 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 1999 TXT starts cold looses spark after 5 seconds
|
09-02-2019, 11:27 AM | #7 |
Not Yet Wild
Join Date: Aug 2019
Posts: 4
|
Re: 1999 TXT starts cold looses spark after 5 seconds
hi thanks for reply, yeah i didn't think it was the starter relay, i was getting 12v to it and 12v out, and it continued to turn over with no spark. also the new parts i don't believe were OEM. I didn't know when ordering them i shouldn't have gotten china junk. so actually maybe one of them is junk. as far as the ground plate goes actually i had taken it off and cleaned it up, and i took of a few of the other ground connections and cleaned them up too. Seeing as though cart is a daily driver at a driving range its been very frustrating not having it. I think I'm at the point, that sadly I am gonna have to bite the bullet and send it out to be looked at. I will post when issues is resolved. thanks for your time, appreciated
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1994 club car ds always starts but takes 30 seconds | Gas Club Car | |||
2008 Yamaha Starts- only runs 2 seconds... | Electric Yamaha | |||
1999 club car 48V charger starts and clicks of after only seconds | Electric Club Car | |||
99 CC Looses Spark | Gas Club Car | |||
my 88 ezgo takes 5 to 15 seconds before it starts | Gas EZGO |