|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
12-22-2016, 11:14 PM | #1 |
Not Yet Wild
Join Date: Dec 2016
Posts: 2
|
36v Club car ds New solenoids still clicking.
Just purchased a 1983 club car 36v. Upon purchasing I went ahead and replaced all five solenoids id using the same resistors. My son an I drove around on the golf cart for hours with problems. After parking and charging for a few hours we went to ride again and now we are getting clicking only from the solenoids. Any suggestions? Also just noticed that 5 of the batteries are 6 volt and 1 is 8 volt. Will this ultimately effect anything or should it be OK?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-23-2016, 06:06 PM | #2 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: 36v Club car ds New solenoids still clicking.
What kinda of solenoids did you buy,the solenoid closest to the steering wheel is the main that lets current flow to the other four.Check to see if if its working also check the the fordward reverse switch if its not getting a good connection will act like your in neutral.
|
12-23-2016, 08:46 PM | #3 |
Not Yet Wild
Join Date: Dec 2016
Posts: 2
|
Re: 36v Club car ds New solenoids still clicking.
I figured it out. The master solenoid although new was bad. Replaced it and all 5 micro switches and it runs like brand new. Thank you.
|
12-24-2016, 08:40 AM | #4 |
Gone Wild
Join Date: Feb 2015
Location: Quad cities
Posts: 334
|
Re: 36v Club car ds New solenoids still clicking.
Glad you got it going these are good carts easy to work on and very simple drive system
|
08-02-2018, 05:45 PM | #5 |
Not Yet Wild
Join Date: Aug 2018
Posts: 1
|
Re: 36v Club car ds New solenoids still clicking.
Question sometimes my cart goes sometimes just clicks and no movement? dont understand replace key switch thought it was it
|
08-05-2018, 11:51 AM | #6 |
Not Yet Wild
Join Date: Jul 2015
Posts: 10
|
Re: 36v Club car ds New solenoids still clicking.
I have a 83 club car ds as well, all my soleniods are inline behind the batteries and click seems no power to the motor but it shows power to it, then anywheres from 30 sec. to about a min. it will decide to run. I tore the motor apart last winter brushes looked good cleaned up the armeture ran great but runs when it wants.
|
08-05-2018, 02:24 PM | #7 |
Guest
Posts: n/a
|
Re: 36v Club car ds New solenoids still clicking.
check all cables & wires .. give them a wiggly and a tug
check the f/r switch recheck solenoids micro switches do not go in and out check motor ... maybe a dead spot ? club car ds [QUOTE=crash test dummy;1370960]KEY ON > F/R SWITCH IN F OR R > GO PEDAL PRESSED > MAIN MICRO SWITCH > MAIN SOLENOID > PRESSING GO PEDAL MORE > 1ST SPEED MICRO SWITCH > 1ST SPEED SOLENOID & ALL COILS > PRESSING GO PEDAL MORE > 2ND SPEED MICRO SWITCH > 2ND SPEED SOLENOID & 2 COILS > PRESSING GO PEDAL MORE > 3RD SPEED MICRO SWITCH > 3RD SPEED SOLENOID & 1 COIL > PRESSING GO PEDAL FULLY > FULL SPEED MICRO SWITCH > FULL SPEED SOLENOID & NO COILS |
|
|
Similar Threads | ||||
Thread | Forum | |||
Solenoids clicking | Electric Club Car | |||
198? Club Car... All Solenoids Clicking, will not go. Working, then not suddenly. | Electric Club Car | |||
solenoids clicking cart not moving | Electric EZGO | |||
are ford solenoids and cc solenoids interchangeable | Gas Club Car | |||
Help - solenoids clicking but cart wont move | Electric Club Car |