lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-10-2018, 12:42 PM   #1
Doughboy305
Not Yet Wild
Club Car
 
Join Date: Sep 2018
Location: Miami, FL
Posts: 23
Default Stuck motor

Ok so I’m once again looking for help I got the cart to roll after what appeared to be a locked up motor now can seem to get the motor off the transaxle any tutorials anyone know of that can assist me in getting this thing off.
Doughboy305 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-10-2018, 02:30 PM   #2
NCPW
Just Gone
 
NCPW's Avatar
Club Car
 
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
Default Re: Stuck motor

Read through this thread

http://www.buggiesgonewild.com/elect...ing-motor.html
NCPW is offline   Reply With Quote
Old 10-10-2018, 02:31 PM   #3
Fairtax4me
Bonafide Nincompoop
 
Fairtax4me's Avatar
Club Car
 
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
Default Re: Stuck motor

Remove the three 1/4 - 20 bolts from around the top and sides of the bell housing.
Remove one 5/16 - 18 bolt from the bottom facing toward passenger side.
Motor should slide off. If it doesn't its due to rust in the splines on the input coupler. Try wiggling it up/down and pry some with a prybar or big screwdriver. If it doesn't move easily you'll have to take the two small screws out of the end of the motor to release the bearing holder, then pull the outer housing off of the armature to get better leverage to pull the armature off of the trans.
Fairtax4me is offline   Reply With Quote
Old 05-21-2019, 03:41 PM   #4
LabRat
Gone Wild
Mixed Breed
 
Join Date: May 2019
Location: Georgia
Posts: 389
Default Re: Stuck motor

The worst stuck motor i experienced was a cart that tried to go swimming, carts don't swim very well. I have replaced hundreds of motors, very seldom i have to pull off the motor case, this time i had to pull the rear end, place in a bench vise with the motor hanging down, several cans of pb blast , pin point heat, banging & praying & after several hours later it fell to the floor. Good luck
LabRat is offline   Reply With Quote
Old 05-22-2019, 07:15 AM   #5
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
Default Re: Stuck motor

https://www.youtube.com/watch?v=EIWnmfVkLIo
TahoeDawgZ71 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
stuck motor Electric EZGO
TXT motor getting stuck Electric EZGO
motor stuck Electric Club Car
stuck pds motor Electric EZGO
Stuck motor Electric Club Car


All times are GMT -5. The time now is 08:43 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.