05-11-2020, 02:19 PM | #1 |
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
6 volt to 8 volt
1990 club car DS. Can I replace one or maybe two of the 6 volt batteries with 8 volt batteries?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-12-2020, 09:58 AM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 6 volt to 8 volt
It has been done before. Not the best way to do it at all, but it has been done. Very hard to charge a pack when it consist of 6v and 8v batteries....
|
05-12-2020, 05:00 PM | #3 |
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: 6 volt to 8 volt
Hey thanks, I checked it today, full charge it's putting out 39.9 volts at the batteries. You'd think that would be plenty of power. Runs great on the flat, but doesn't like hills. Drops to 4 or 5 mph.
|
05-12-2020, 06:30 PM | #4 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 6 volt to 8 volt
I would not mix 6v and 8v batteries. As Nole said, charging is a challenge, if they're mixed they will never charge properly. How old are your current batteries? They may read fine while at rest, but under a load they're dropping. Also, these old series carts are not speed demons, 10-12 mph is about all they'll do on flat ground, and even slower uphill.
|
05-13-2020, 02:15 PM | #5 |
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: 6 volt to 8 volt
Thanks, I'm going to leave it alone. The batteries are only 2 years old, but tested under load 2 of them were at only 3 or 4 volts. So I replaced those 2. You're right, it runs about 12 on the flat. We have a lot of hills and it will slow to about 4 mph on the steep ones. I installed a battery meter and they seem to stay charged for a long time. I've driven it two time for a total of about 4 miles, and the meter shows fully charged.
|
05-13-2020, 02:40 PM | #6 | |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 6 volt to 8 volt
Quote:
|
|
05-13-2020, 10:02 PM | #7 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 6 volt to 8 volt
Good deal
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Light Connection for 2006 Precedent after 12 Volt - 8 Volt Conversion | Electric Club Car | |||
placement when adding 2 more 6 volt batteries to 36 volt for 48 volt conversion | Electric Club Car | |||
1990 Club Car DS 36 volt to 48 volt conversion fitting batteries question | Electric Club Car | |||
2003 48 volt CC....installed 6-6volt batteries instead of 6-8 volt | Electric Club Car | |||
Volt reading when Isolating 2 6v batts, is seperate volt meter needed? | Electric EZGO |