|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-04-2020, 05:39 AM | #11 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
This helps to see what it attaches to, I hate to remove motor but may have to, glad I’m not the only one that has does this
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-04-2020, 05:40 AM | #12 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
Tow mode kills power to motor right or should I remove battery cables?
|
04-04-2020, 06:11 AM | #13 |
Gone Wild
Join Date: Sep 2016
Location: Titusville, FL...Space Coast
Posts: 591
|
Re: 2006 club car ds, motor problem
Tow mode and remove the pack pos and neg cables...
|
04-04-2020, 12:25 PM | #14 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2006 club car ds, motor problem
Yes, definitely remove at least one cable too
|
04-04-2020, 08:36 PM | #15 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
Thanks guys I finally got it, used a 2” screw like Movin-on suggested and got it back together without pulling the motor. That was the good news, the bad is the cart is still acting up. I may need to open other thread but it runs but going up a hill or after a few minutes it drops to a lower speed or quits and you have to let up off the pedal and press again and starts back and keeps doing the cycle again. Any ideas? I checked all the wires and the magnet of course
|
04-04-2020, 08:57 PM | #16 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2006 club car ds, motor problem
Could be your MCOR acting up. Pump your go pedal 30 times and then see if things improve. If it gets better, replace your MCOR.
|
04-04-2020, 09:02 PM | #17 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
Thank I will give it a try
|
04-09-2020, 12:15 PM | #18 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
Ok I pumped it, for about 10-15 times with no response then last 15 or so it jerked like it was ready to go. After trying this the problem still exists
|
04-09-2020, 12:18 PM | #19 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2006 club car ds, motor problem
Conduct a speed sensor test: http://www.buggiesgonewild.com/showthread.php?t=68248
|
04-09-2020, 12:49 PM | #20 |
Not Yet Wild
Join Date: Aug 2009
Posts: 52
|
Re: 2006 club car ds, motor problem
Just tried again, it has been on charged, backed up fine then forward for a little ways at normal speed then quit pressed go pedal and goes but very slow. Rode around a little but says at slow speed any ideas?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2006 Club Car Precedent FE350 gas in oil problem | Gas Club Car | |||
2006 Club Cart DS Charging Problem | Electric Club Car | |||
2006 DS IQ w/upgraded motor & controller having throttle problem | Electric Club Car | |||
2006 club car starting problem. | Electric Club Car | |||
2006 48v electric club car charging problem | Electric Club Car |