09-30-2013, 07:51 PM | #1 |
Gone Wild
Join Date: Aug 2012
Location: Tampa Bay area
Posts: 220
|
02 ds cc gas wont start
Just got a gas CC DS from a buddy. Battery needed charging at first. Cart ran after that. Then, cart would only run/start in reverse. Yes, reverse waning horn sounds. I messed with the yellow maint switch behind the F&R, Now, cant get it to start in F or R. I've tried every position of that switch now and nothing. Load tested battery and it is holding up. What do I check next?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-01-2013, 11:36 AM | #2 |
Gone Wild
Join Date: Jul 2012
Location: S.E. WIS
Posts: 176
|
Re: 02 ds cc gas wont start
not real familar with the 02's but maybe your mirco switches are bad. Will the motor turn over but not start or does it not even turn over? Maybe solenoid is going bad - try jumping it and see if it turns over.
|
10-02-2013, 11:31 AM | #3 |
Gone Wild
Join Date: Aug 2012
Location: Tampa Bay area
Posts: 220
|
Re: 02 ds cc gas wont start
The cart does not turn over at all. I get nothing. so that why I'm thinking it's electrical....
Other than micro switch, anyone have any other suggestions? |
10-02-2013, 01:17 PM | #4 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: 02 ds cc gas wont start
Did you check the 10A fuse in the electrical components box?
|
10-02-2013, 02:01 PM | #5 |
Getting Wild
Join Date: Sep 2012
Location: Tennessee
Posts: 94
|
Re: 02 ds cc gas wont start
Very silly question. You said you "messed with the yellow maint switch" and now it wont start in F or R. Have you tried it in neutral?
|
10-02-2013, 05:00 PM | #6 |
Gone Wild
Join Date: Jul 2012
Location: S.E. WIS
Posts: 176
|
Re: 02 ds cc gas wont start
jump the solenoid and see if it turns over or check the fuse as LOCKMAN suggested
|
10-03-2013, 11:24 AM | #7 |
Gone Wild
Join Date: Aug 2012
Location: Tampa Bay area
Posts: 220
|
Re: 02 ds cc gas wont start
It will not start in nuetral either. As for the fuse, can you direct me to the location or show me pics of location? This is first gas cart that I have looked under the seat at. As for solonoid, can you give me a proceedure for jumping that?
Thanks for all the suggestions!! |
10-03-2013, 11:54 AM | #8 |
Gone Wild
Join Date: Jul 2012
Location: S.E. WIS
Posts: 176
|
Re: 02 ds cc gas wont start
The fuse panel should be located in the black box that holds the micro switches, throttle cable arm, and solenoid. I believe all the fuses are 10amp. There are four slots as seen in the pics below. just underneath the solenoid. Pull each one and make sure they are good. Take a screw driver, wrench, or wire and jump the two larger posts on the solenoid (see pic) and that will engage the starter generator and should turn the motor over. It may not start depending upon your issue but the motor should turn over if your starter generator is good.
|
10-04-2013, 06:16 AM | #9 |
Gone Wild
Join Date: Aug 2012
Location: Tampa Bay area
Posts: 220
|
Re: 02 ds cc gas wont start
Thanks everyone and Clubcar5!
Jumped the solinoid: Working! Pulled several fuses: Found a bad 15 amp, coming off the pos term of battery! Forward gear Microswitch does not fully activate when lever in fwd position. *********** Replaced fuse and slightly bent the arm of the microswitch to get a better connection. All seems to be working now!!! Thanks for all the suggestions!!! |
10-04-2013, 01:57 PM | #10 |
Gone Wild
Join Date: Jul 2012
Location: S.E. WIS
Posts: 176
|
Re: 02 ds cc gas wont start
Good to hear your up and running!!!!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
gas txt wont start | Gas EZGO | |||
par car wont start | Gas Columbia ParCar | |||
'94 CC wont start | Gas Club Car | |||
04' Wont Start? | Gas Yamaha | |||
wont start. | Gas Yamaha |