|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-29-2009, 01:19 PM | #1 |
Not Yet Wild
Join Date: Apr 2009
Posts: 14
|
engine wont fire unless I spritz gas thru the choke
Hi folks. i have an older 80's model EZGO (gas) that I putter around on.
This spring she wont fire unless I spray a little gas thru the carb. I changed plugs, cleaned carb (twice!). If i spray gas or carb cleaner in she fires right up, but will not continue to run. Any suggestions will be appreciated. mark |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-29-2009, 01:26 PM | #2 |
Hey Wally, its the Beaver
Join Date: Apr 2009
Location: North Dakota
Posts: 1,206
|
Re: engine wont fire unless I spritz gas thru the choke
Have you checked the fuel filter. Also i would start by checking to see if the fuel pump is working. When you took the carb off to clean it was there gas in it??
|
04-29-2009, 01:30 PM | #3 |
Not Yet Wild
Join Date: Apr 2009
Posts: 14
|
Re: engine wont fire unless I spritz gas thru the choke
I apologize for not telling more of what I have done!
yes, the fuel pump is pumping. I can that the gas line line off at the carb and it is pumping well, and the bowl on the carb fills up. fresh gas too.... thanks m |
04-29-2009, 01:46 PM | #4 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: engine wont fire unless I spritz gas thru the choke
Did you pull the carb and clean it or just spray it? Is the air box and filter on?
|
04-29-2009, 08:45 PM | #5 |
Gone Wild
Join Date: Jan 2009
Location: Alabama
Posts: 2,120
|
Re: engine wont fire unless I spritz gas thru the choke
Sounds like there's a plugged jet in your carb.
Be SURE you have a good gasket between the carb and the head. (carb and cyl. on 2 cycle) air at this point will prevent fuel from being drawn into the cylinder or head. Other than that??..........vacuum line and fuel lines?? If you don't have an in-line fuel filter, install one, if you do, replace it. |
04-29-2009, 08:47 PM | #6 |
Not Yet Wild
Join Date: Apr 2009
Posts: 14
|
Re: engine wont fire unless I spritz gas thru the choke
i have not put the filter and air box back on. i did not think that would have any effect on ignition..
|
04-29-2009, 08:54 PM | #7 |
Not Yet Wild
Join Date: Apr 2009
Posts: 14
|
Re: engine wont fire unless I spritz gas thru the choke
i sprayed the heck out of carb cleaner thru the carb. pulled the needle valve out of the carb and sprayed cleaner. it seems clean. does not seem like there is much more to break down on it. any suggestions?
by the way, where is the vacuum line? thanks. m |
04-29-2009, 09:05 PM | #8 |
Gone Wild
Join Date: Jan 2009
Location: Alabama
Posts: 2,120
|
Re: engine wont fire unless I spritz gas thru the choke
My carts fuel pump has three lines to it. one of those runs back to the motor to pickup vacuum to operate the pump. The other 2 lines are in - out for fuel. I dont think ours are the same, mine is a 99!
|
04-29-2009, 09:08 PM | #9 |
Not Yet Wild
Join Date: Apr 2009
Posts: 14
|
Re: engine wont fire unless I spritz gas thru the choke
yes mine does too. the fule pump seems to work well. there is gas pumping to the carb and the bowl on the carb fill up.
|
04-29-2009, 09:13 PM | #10 |
****tard supreme
Join Date: Jun 2008
Location: waldo,wisconsin
Posts: 5,401
|
Re: engine wont fire unless I spritz gas thru the choke
you do have good compression?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
The belts are turning but engine wont catch | Gas EZGO | |||
robin engine wont ilde | Gas EZGO | |||
My G1 needs too much Choke | Gas Yamaha | |||
Engine Choke??? | Gas EZGO |