|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-07-2010, 10:35 AM | #1 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
forward reverse switch wiring
Following the the 86 to 95 with v glide diagram, I have two broken wires. #22 and 24, blue and yellow. The cart does not move at all. One comes from the key, and the yellow is a small one off of the solenoid. The diagram shows them both going to the forward reverse switch. My problem is the diagram is too vague to see where on the switch they go.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-07-2010, 10:39 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: forward reverse switch wiring
Welcome to bgw. I believe they go to the F&R micro switch.
|
06-07-2010, 10:48 AM | #3 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
There is one open terminal on the micro switch. I tried to put the one from the key to it and it grounds out and starts to melt.
|
06-07-2010, 10:49 AM | #4 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
I bought the cart like this. The guys kid hit a rail with it and did a little fiberglass damage to the front of the compartment. When it did, it pulled the two wires out and he never found where they went, so it sat for the winter. He swears it ran till the accident.
|
06-07-2010, 10:52 AM | #5 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: forward reverse switch wiring
It is tough to do this without a meter, huh? ... it may be the one going to the solenoid activation circuit then... and the other one to the micro. Check to see if the micro is still good, they won't take much of that direct short to melt.
|
06-07-2010, 10:58 AM | #6 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
I know. My meter is at work and I am off today. I can't believe I can't find the two ends still stuck where they belong. The wires are bare on the end. I am assuming the one off the key is a ground.
|
06-07-2010, 11:18 AM | #7 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: forward reverse switch wiring
The blue wire from the key should go to the V-glide micro..
Canyou post the diagram you are working with? What yr is your cart? |
06-07-2010, 11:36 AM | #8 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
http://www.buggiesgonewild.com/elect...-diagrams.html
It is the 88 to 03 vglide diagram. I just went out and bought a meter. A ride to work would take 3 hours round trip at this time of the day. |
06-07-2010, 11:43 AM | #9 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
Both appear to be ground wires.
|
06-07-2010, 12:55 PM | #10 |
Not Yet Wild
Join Date: Jun 2010
Location: Brick, NJ
Posts: 18
|
Re: forward reverse switch wiring
I got it running. Thanks for the help. Key wire went to one side of the coil. Coil clicks when key it turned. Other went to the forward reverse switch. Got it charging so I can go for a cruise later. Thanks.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
forward/reverse switch change to toggle switch | Electric Club Car | |||
Question about wiring from forward/reverse switch | Electric EZGO | |||
forward/reverse switch wiring | Electric Club Car | |||
Wiring 36V Forward Reverse Switch 95CC | Electric Club Car | |||
Forward Reverse switch melted on forward...have question about replacement part | Electric Club Car |