|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-19-2017, 07:51 PM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 3
|
06 IQ precedent, won't move
I am working on an 06 IQ precedent serial number PQ0637-677208. It was brought to me not moving at all and the resistor getting extremely hot, it actually melted part of the heat shrink on it. I got a new resistor and put on it, but they old one ohmed out the same as the new. The solenoid would not click at all and i did other tests and suspected the controller to be bad. Through the process of unhooking stuff and plugging stuff back in i heard the controller sizzle and a small amount of the magic smoke was let out. Now the solenoid will click and after 1-4 seconds it will click again and the cart will still not move. I want to make sure it is just the controller before i send it off to get repaired. Batteries are showing 47.8 volts, motor ohmed out ok, the MCOR is at least telling the controller to click on the solenoid now.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-20-2017, 05:55 PM | #2 |
Gone Wild
Join Date: May 2013
Posts: 552
|
06 IQ precedent, won't move
Bump for him
|
04-20-2017, 08:49 PM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 06 IQ precedent, won't move
The batteries are very weak. 47.8 is DEAD, That's probably a direct result of the short in your controller causing the resistor to get hot. Replace the controller and charge the batteries and you should be good to go.
|
05-02-2017, 07:12 PM | #4 |
Not Yet Wild
Join Date: Apr 2017
Posts: 3
|
Re: 06 IQ precedent, won't move
Replaced the controller and went to hook up the cables back to the batteries and when i did there was a large spark, a lot larger than i think should be with the cart off. When i unplug the red wire that hooks to the solenoid, i believe it goes to the obc, and then hook the batteries back up there is no spark. Haven't tried to move the cart yet because the large spark makes me think i have another short
|
05-02-2017, 07:17 PM | #5 |
Gone Wild
Join Date: Oct 2014
Location: Fort Worth, Tx
Posts: 500
|
Re: 06 IQ precedent, won't move
I always hook the ground up last to avoid the spark.
Sent from my SM-J710MN using Tapatalk |
05-02-2017, 07:39 PM | #6 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 06 IQ precedent, won't move
Was your TOW/RUN switch in the TOW position when you reconnected the batteries?
|
05-02-2017, 08:17 PM | #7 |
Not Yet Wild
Join Date: Apr 2017
Posts: 3
|
Re: 06 IQ precedent, won't move
i think it was in run. I went ahead and just hooked it up anyway, lol. Everything is working great. Thank you for your help.
|
05-02-2017, 09:33 PM | #8 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 06 IQ precedent, won't move
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Club Car Precedent won't move | Electric Club Car | |||
precedent doesn't move all the time | Electric Club Car | |||
04 precedent will not move | Electric Club Car | |||
Precedent won't move and I'm out of ideas... | Electric Club Car | |||
Precedent cart will not move | Electric Club Car |