|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-22-2013, 09:20 PM | #1 |
Not Yet Wild
Join Date: Dec 2012
Posts: 15
|
g2 wont pump fuel.
So here the deal.
i have a g2 that wont pump fuel .. I rebuilt the pump put new fuel and vaacum lines on it.checked compression 110 lbs.still wont pump fuel. What am i missing? And yes the pump is together correctly. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-24-2013, 05:24 PM | #2 |
Not Yet Wild
Join Date: Apr 2012
Posts: 1
|
Re: g2 wont pump fuel.
If it is a pulse type pump, check the vacuum lines for leaks and the crankcase seal. My buddies G1 has a bad crankcase seal and won't run either.
http://www.buggiesgonewild.com/gas-y...fuel-pump.html |
04-24-2013, 07:54 PM | #3 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,874
|
Re: g2 wont pump fuel.
Your G2 should have 155 to 175 pounds of compression at wide open throttle. The fuel pump runs off crank case pressure, that is generated of of ring compression.
|
04-24-2013, 09:47 PM | #4 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: g2 wont pump fuel.
Did you check the filter, its at bottom of tank but huge so they don't clog very often. Note the pumps have a hard time priming if you don't have much gas in tank, best to fill it up if air in lines, you can pressurize the tank but be very careful you only use a very little bit of pressure to push the fuel out. Have you run it on the starter with the line off the carb to check flow?
|
04-26-2013, 06:44 PM | #5 |
Not Yet Wild
Join Date: Dec 2012
Posts: 15
|
Re: g2 wont pump fuel.
Thanks guys.
i had to kinda force prime the pump with a small amount of compressed air. its running pretty good for now. |
04-26-2013, 07:42 PM | #6 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: g2 wont pump fuel.
Good deal. If you just ran out of fuel you can add it and usually it will start fairly soon. If you take a line off or the pump/etc it has a hard time priming, some carts will some will not. If the fuel level is up to the pump or higher it usually will no problem. IIRC yamaha says to fill the tank if you run out.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
1988 Parcar Fuel pump Or no Fuel pump? | Gas Columbia ParCar | |||
g1 new fuel pump still wont pump HELP | Gas Yamaha | |||
fuel pump not putting out fuel | Gas EZGO | |||
Fuel Pump | Gas EZGO | |||
fuel pump | Gas Club Car |