|
|
|||||||
| Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
  |
|
|
Thread Tools | Display Modes |
04-25-2020, 08:25 PM
|
#1 |
|
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Weird issue on TXT
I replaced the batteries on my 12 TXT. Everything worked fine for 3 days. I went to wire up a voltage meter today and it worked when I tested it to the battery. When I tested the wires on the back of the switch, the white wire was hot. I aires in the positive side of the meter to that wire and then ran the negative side straight to the negative battery terminal. When to test it and nothing. I put everything back the way it was and went to go for a ride and now I have no power at all. I went to check the voltage across the batteries and it threw sparks. Any ideas? It’s almost like the cart reversed polarity.
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
04-25-2020, 08:39 PM
|
#2 |
|
Gone Wild
 Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,127
|
Re: Weird issue on TXT
White should have pack + voltage whenever the run tow switch is in run. White/yellow stripe will have voltage when the switch is turned on. Does the reverse buzzer work?
|
|
|
|
|
04-25-2020, 09:03 PM
|
#3 | |
|
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: Weird issue on TXT
Quote:
|
|
|
|
|
|
04-25-2020, 09:46 PM
|
#4 |
|
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Weird issue on TXT
Are you sure you aren't the one who reversed the cart polarity? If you did, bend over & pull out your wallet, it's about to get bad. The cart wont tolerate it, not even once, not for a second.
|
|
|
|
|
04-25-2020, 10:19 PM
|
#5 |
|
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: Weird issue on TXT
 to BGW |
|
|
|
|
04-25-2020, 10:53 PM
|
#6 | |
|
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: Weird issue on TXT
Quote:
|
|
|
|
|
|
04-25-2020, 10:57 PM
|
#7 | |
|
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: Weird issue on TXT
Quote:
|
|
|
|
|
|
04-25-2020, 11:21 PM
|
#8 |
|
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: Weird issue on TXT
Correct but it worked fine for 3 days after replacing them.
|
|
|
|
|
04-26-2020, 11:14 AM
|
#9 |
|
Not Yet Wild
Join Date: Apr 2020
Posts: 7
|
Re: Weird issue on TXT
Update.... I fed did all of the cables connecting the batteries and the arcing stopped. I’m at 38.4 volts across the bank. I have 38.4 volts on the positive side of the solenoid and 36.4 volts on the controller side of the solenoid. The solenoid does not click when i press the pedal.
When i check the voltage at the key switch they are both 0. Any ideas? |
|
|
|
|
04-26-2020, 11:59 AM
|
#10 |
|
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,127
|
Re: Weird issue on TXT
Check voltage at the run/tow switch. If it has voltage on both sides you fried a wire somewhere. I haven’t worked on the 48txt much so don’t remember if it has a fuse anywhere. I have attached a diagram
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 97 DS Weird issue | Electric Club Car | |||
| Weird alignment issue | Lifted Golf Carts | |||
| G22 Really Weird Starting issue, nvr seen before | Gas Yamaha | |||
| Wiring issue, really weird! | Gas Club Car | |||
| Weird Battery Issue Or Something Else? | Electric EZGO | |||
Linear Mode
