|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-08-2019, 02:55 PM | #1 |
Getting Wild
Join Date: Nov 2015
Posts: 77
|
2006 48V CC DS will not run.
I have a 2006 DS 48V and have replaced just about everything. Computer, Controller, MCOR, solenoid. Key switch, forward/reverse switch and Tow/Run switches check out good.
It charges fine. In RUN with ignition on, in reverse the buzzer sounds, but the solenoid does not close. Same in Forward. At a loss...anyone have any ideas. IS there something I need to reset? Thanks, Ken |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-08-2019, 08:34 PM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 2006 48V CC DS will not run.
Have you tested the inputs at the 2 small post/tabs of the solenoid?
|
07-09-2019, 02:36 PM | #3 |
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2006 48V CC DS will not run.
Yes..no voltage to the coil. Have continuity tested the MCOR back to the controller, The wires to the solenoid coil, TOW/RUN switch, Forward/Reverse switch. All good. All points to the controller, but this controller is new. I just want to make sure it is a faulty controller.
|
07-09-2019, 02:40 PM | #4 |
Gone Wild
Join Date: May 2019
Location: Georgia
Posts: 389
|
Re: 2006 48V CC DS will not run.
are you sure that the 2 wire for the foot pedal micro is good at the MCOR. I have seen dozens of MCOR that has a good pot but a bad micro switch, Try to jump these 2 to see
|
07-09-2019, 02:52 PM | #5 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 2006 48V CC DS will not run.
The controller pulls the low (-) for the coil, but the high (+) comes from the Key On and Run tow switch in Run along with good connections at the 3 sonic welds and wiring. Need to search that one out first....
|
07-09-2019, 08:44 PM | #6 |
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2006 48V CC DS will not run.
I found the problem. The green power wire that runs from the key switch was open in the wiring harness. Ran a new wire and all is good now.
Thanks for all your help. Ken |
07-10-2019, 03:35 AM | #7 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 2006 48V CC DS will not run.
Glad you are rolling again....
|
|
|
Similar Threads | ||||
Thread | Forum | |||
OBC off of 2006 CC | Golf Carts and Parts | |||
2006 G22 Will not go 48v | Electric Yamaha | |||
2006 does nothing | Electric Club Car | |||
2006 cc DS IQ | Electric Club Car | |||
2006-08 CC DS with IQ | Electric Club Car |