|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-04-2013, 02:03 PM | #1 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
1999 TXT runs in and out
I am going to do my best at describing this...This cart is a 1999 TXT.When the gas pedal is pushed down the cart will run but motor sounds inconsistent.It sounds as if the motor cuts in and out but the motor does not actually cut out.For one second the motor will sound higher then the next second it sounds slightly lower,then the next second back to higher,then the next second lower.....I am trying here....So we removed the carb thinking jet was clogged not allowing good flow of fuel. The bracket holding the pin for the float was broke.We replaced with a new carburetor and the cart is doing the same thing.If anyone has a thought,pleeeez share with me.
thanks so much for your time. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-05-2013, 01:13 AM | #2 |
Gone Wild
Join Date: Feb 2013
Location: Plant City, FL
Posts: 2,212
|
Re: 1999 TXT runs in and out
I don't know a whole but I was just wondering if it made a difference if you adjusted the choke at all.
|
06-05-2013, 05:52 AM | #3 |
Not Yet Wild
Join Date: Oct 2012
Posts: 58
|
Re: 1999 TXT runs in and out
how are the valves
|
06-05-2013, 08:45 AM | #4 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1999 TXT runs in and out
A new choke cable was installed because the cart did not have one. Also we opened the valve cover to check them and they were practically stuck shut. They have been adjusted to spec. of .004 and now the cart runs even worse. Not sure what else to do.
|
06-05-2013, 10:34 AM | #5 |
Gone Wild
Join Date: Feb 2013
Location: Plant City, FL
Posts: 2,212
|
Re: 1999 TXT runs in and out
What I meant was does the engine run any different if you pulled the choke out 1/4, 1/2 a way? Does it run any different with the air box open? Have you checked the fuel pump? Are you getting good spark? How does it run at half throttle?
|
06-06-2013, 02:44 PM | #6 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1999 TXT runs in and out
Well the cart runs the same with the air box open and filter removed. Checked the fuel pump and it is working. The spark seems to be fine at this point. What we did notice is the situation does get worse after the cart gets warmed up. We did change the pulsar coil for the heck of it and it is still doing the same thing. Remember it doesn't actually cut out completely. Weird. We are at a loss
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Runs 10 minutes then shuts off, wait 5 then runs again... | Electric EZGO | |||
1999 48 volt club car IQ barely runs slow | Electric Club Car | |||
G1, idles great, runs rough, runs better when warm | Gas Yamaha | |||
runs good cold runs bad hot? | Gas EZGO | |||
Reverse...runs awesome Forward..runs bad | Gas EZGO |