|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-30-2017, 09:43 AM | #1 |
Not Yet Wild
Join Date: Feb 2017
Location: SouthWest Florida
Posts: 21
|
Did conversion - no go after taking foot off the pedal!?
'92 DS CC converted over with C42 package from ScottyB.
Alltrac SR48400. Also installed the converter. Finally lowered it to the ground to take it for a test run. Runs fine until you take your foot off the pedal. The minute you stop it will not run again. Have to turn key off then back on and then it will go again. Noticing when it will not run that the voltage meter goes way down and my 12v readout on my usb accessory goes to a crazy reading. Something amiss but not sure what? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-30-2017, 10:43 AM | #2 |
Gone Wild
Join Date: Oct 2010
Location: New Braunfels TX
Posts: 194
|
Re: Did conversion - no go after taking foot off the pedal!?
You will probably need to put it on jack stands and open the motor hatch to see it but the altrax has a light on it that will give you a blink code if the controller has encountered a problem or will not light at all if the controller is not getting voltage when you re-press the pedal.
|
04-30-2017, 11:09 AM | #3 | |
Not Yet Wild
Join Date: Feb 2017
Location: SouthWest Florida
Posts: 21
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
|
|
04-30-2017, 11:55 AM | #4 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Did conversion - no go after taking foot off the pedal!?
LED on the control turns orange (+ or - orange) at full pedal, that is correct for all The Alltrax controllers. When the solenoid clicks the LED should flash once to indicate 0-5k throttle and then go solid green, this single then solid green turning to orange at full pedal indicates the control is programmed correctly and working.
Check your source for the solenoid activation.... where does that + come from originally? It should come from battery pack main + to keyswitch, to F&R micro-switch(ms), to potentiometer (pot) ms, to solenoid small + and control F1 red. This pathway here is what you should concentrate on troubleshooting. |
04-30-2017, 12:15 PM | #5 | |
Not Yet Wild
Join Date: Feb 2017
Location: SouthWest Florida
Posts: 21
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
|
|
04-30-2017, 12:38 PM | #6 | |
Not Yet Wild
Join Date: Feb 2017
Location: SouthWest Florida
Posts: 21
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
Sent from my VS990 using Tapatalk |
|
04-30-2017, 12:59 PM | #7 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
Are you sure the throttle lever is coming all the way up when you let off the gas. Did you put the throttle rod extension on? If the pot is not going to zero position that could cause a high pedal disable HPD situation until you turn the controller off or the pedal comes to zero. |
|
04-30-2017, 01:08 PM | #8 | |
Not Yet Wild
Join Date: Feb 2017
Location: SouthWest Florida
Posts: 21
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
The 36v+ key source was not coming from the right place. I switched it to the battery main+ and now it works like a charm. My bad. I "almost" had it wired like in your diagram. Was on the wrong side of the big solenoid. |
|
04-30-2017, 02:48 PM | #9 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Did conversion - no go after taking foot off the pedal!?
Quote:
I didn't know that could be done Resistor allowed enough voltage to engage the solenoid 1 time. |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Power cuts when taking foot off gas | Electric EZGO | |||
Foot Pedal Starter Not Working | Gas EZGO | |||
Cart runs with foot off pedal | Electric EZGO | |||
05 Precedent...foot pedal wiring | Electric Club Car | |||
precedent foot pedal | Golf Carts and Parts |