|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-29-2009, 10:48 PM | #1 |
Not Yet Wild
Join Date: Jun 2008
Posts: 4
|
89 marathon runs stalls runs stalls
I'm trying to solve my 89 ezgo fuel issue. Will start fine, run for several minutes, then begin to lose power and finally quits. Can wait a couple minutes and with a small amount of choke will take off and run another few hundred yards or longer before going thru the same symptoms.
Took carb off and cleaned with wire tie and carb cleaner. Carb looked clean and no debris in bowl. Replaced fuel filter with no change. Filter appears to not be even half full of fuel at any time and when it stops it looks only about 1/8 full. Mixing my fuel and oil. My next step is to check fuel pump by removing line to carb and letting motor turn over. Please give me some ideas on some other things to check. Thanks much for any help I can get!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-30-2009, 02:07 AM | #2 |
It ain't gonna be easy.
Join Date: Apr 2008
Location: St. George, SC
Posts: 1,480
|
Re: 89 marathon runs stalls runs stalls
i would start there 4 sure.
|
07-30-2009, 07:41 AM | #3 |
Not Yet Wild
Join Date: Jul 2009
Posts: 4
|
Re: 89 marathon runs stalls runs stalls
check the oil level,do not overfill..and check the venthose to the crank case from the airbox..empty the carburator bowl with the drain screw
|
07-30-2009, 12:11 PM | #4 |
It ain't gonna be easy.
Join Date: Apr 2008
Location: St. George, SC
Posts: 1,480
|
Re: 89 marathon runs stalls runs stalls
|
07-30-2009, 12:47 PM | #5 |
Gone Wild
Join Date: Jan 2009
Location: Alabama
Posts: 2,120
|
Re: 89 marathon runs stalls runs stalls
Be sure the fuel tank vent is operating. Most vents are in the fuel cap, others the tank has a vent hose.
Fuel filters don't fill up with fuel (unless gravity fed), but they can look clean and not be. The fuel pump test will tell you the rest...I think Good Luck. Let us know what it is....or what happens. |
07-30-2009, 12:50 PM | #6 |
Gone Wild
Join Date: Jan 2009
Location: Alabama
Posts: 2,120
|
Re: 89 marathon runs stalls runs stalls
Welcome To BGW!Everyone!
|
07-31-2009, 08:03 AM | #7 |
Not Yet Wild
Join Date: Jun 2008
Posts: 4
|
Re: 89 marathon runs stalls runs stalls
Thanks for the new tips!! Will be heading to the campground today and will let you know how things went.
|
07-31-2009, 04:06 PM | #8 |
Not Yet Wild
Join Date: Jul 2009
Location: mn
Posts: 10
|
Re: 89 marathon runs stalls runs stalls
mine acted like that because crank seal was out.
|
08-02-2009, 08:53 PM | #9 |
Not Yet Wild
Join Date: Jun 2008
Posts: 4
|
Re: 89 marathon runs stalls runs stalls
As usual, took the second round of carb cleaning to get it solved. Can't say enough about carb cleaner and compressed air!!!!!!!!!!!!
Runs well. Might need some clutch work but I'm going to enjoy it for now. Thanks everybody |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Runs 10 minutes then shuts off, wait 5 then runs again... | Electric EZGO | |||
Cart stalls | Electric Club Car | |||
99 club car starts and stalls...help | Gas Club Car | |||
Stalls periodically | Electric EZGO | |||
Cart Stalls | Electric EZGO |