|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-11-2017, 12:28 AM | #1 |
Not Yet Wild
Join Date: Aug 2012
Location: Indiana
Posts: 70
|
96' Gas Club Car Slow Turning over
I have a 1996 Gas Club Car with the FE350 engine. The problem I am having is it's slow to start when I press on the gas pedal. Once it starts turning over there is no issue, it starts right up. You can watch the starter motor hesitate, than it will start turning normally.
-I have a 6 month old battery that is checking good. - I have replaced the brushes to the starter generator. The armature was cleaned off using fine sandpaper. The (windings?) inside the motor housing looked good, and I didn't notice anything out of the ordinary. Any suggestions? Thanks in advance |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-11-2017, 11:57 AM | #2 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 96' Gas Club Car Slow Turning over
The starter isn't slipping the belt is it?
|
04-11-2017, 12:20 PM | #3 |
Not Yet Wild
Join Date: Aug 2012
Location: Indiana
Posts: 70
|
Re: 96' Gas Club Car Slow Turning over
No, not all...that was one of my first things to check. Had that happen couple yrs ago, replaced the belt didn't slip again. I recently adjusted it when I put the new brushes in. It has always had the hesitation, even after new belt. With no belt on it, the starter motor takes right off.
|
04-11-2017, 04:32 PM | #4 | |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 96' Gas Club Car Slow Turning over
Quote:
|
|
04-11-2017, 05:21 PM | #5 |
Not Yet Wild
Join Date: Aug 2012
Location: Indiana
Posts: 70
|
Re: 96' Gas Club Car Slow Turning over
Checking at the solenoid when cranking I only had like 11.2 volts. Could it be battery? It has done this with old battery and the new one.
|
04-11-2017, 06:42 PM | #6 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 96' Gas Club Car Slow Turning over
That seems to be ok on the voltage while cranking. Is the motor hard to turn by hand? S/G may need rebuild.
|
04-11-2017, 08:14 PM | #7 |
Not Yet Wild
Join Date: Aug 2012
Location: Indiana
Posts: 70
|
Re: 96' Gas Club Car Slow Turning over
Motor isn't any harder to turn than other club car. I may need to rebuild it, or replace it.
|
Tags |
battery, brushes, soleniod, starter generator, voltage regulator |
|
|
Similar Threads | ||||
Thread | Forum | |||
Club Car squeaks when turning | Electric Club Car | |||
1992 Parcar slow turning over, fast with spark plug removed | Gas Columbia ParCar | |||
turning a club car into a submarine | Gas golf carts | |||
Starter turning too slow to start | Gas EZGO | |||
Slow turning starter | Gas EZGO |