|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-21-2020, 10:01 PM | #1 |
Not Yet Wild
Join Date: Aug 2019
Location: satsama al
Posts: 8
|
txt wont do nothing
hello guys i have a 2015 txt that wont do anything solenoid want click wont move 51.1 volts @ battery pack have 51.1 @ sol big term and lil term w key on new sol read several post getting mixed reviews as controller or f r switch dont know which way to go thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-22-2020, 02:47 AM | #2 |
Gone Wild
Join Date: Jul 2012
Posts: 527
|
Re: txt wont do nothing
Im not sure what cart you have exactly, but I think this thread may be discussing the solenoid activation circuit for your cart:
https://www.buggiesgonewild.com/showthread.php?t=122075 Sounds like if you are getting 48v across small posts on solenoid and it isn’t energizing, the solenoid is bad. If this is the case you should be able to bypass solenoid to test. Hope it helps. |
08-22-2020, 07:47 AM | #3 |
Gone Wild
Join Date: Feb 2020
Location: Naples FL
Posts: 455
|
Re: txt wont do nothing
check the connector from the throttle pedal to the controller. after upgrading the controller my txt did that and there was a little corrosion on that connector, I cleaned it up and was GTG
|
08-22-2020, 04:09 PM | #4 |
Not Yet Wild
Join Date: Aug 2019
Location: satsama al
Posts: 8
|
Re: txt wont do nothing
thanks guys no ele brake georgia088
|
08-22-2020, 06:23 PM | #5 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: txt wont do nothing
Sounds like you have a 2015 TXT-48.
If you have battery pack voltage on the solenoid's small terminal with a yellow wire on it, check for pack voltage on the small terminal with the blue wire on it. If it is there, than the problem is the main coil driver inside the controller isn't connecting the blue wire to B- when pedal is pushed. Could be a bad pedal switch. Check for pack voltage on Pin-6 (green wire) when pedal is pushed. Also could be bad charge disable from the charge receptacle (blue wire at receptacle). Check for pack voltage on Pin-5. Without it, the controller is disabled. Also check for pack voltage on Pin-8 with F/R in F. (Or Pin-16 when in R) Also check for voltage on Pin-9 If you have battery pack voltage on Pins 5, 6, 9 and 8 or 16 when there should be and solenoid isn't clicking, chance are the controller is bad. If so, replace it with an Alltrax XCT48400-TXT48 (or larger). |
08-23-2020, 06:28 PM | #6 |
Not Yet Wild
Join Date: Aug 2019
Location: satsama al
Posts: 8
|
Re: txt wont do nothing
thank you guys i found problem it was the ITS in the black box in the floor looks like it done rub down to the coil
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Wont stop beeping and wont move | Electric EZGO | |||
420cc predator key switch wont engage start and wont charge | Clone Engine Swaps | |||
96 club car ds solenoid wont click and cart wont move unless you jump solenoid | Electric Club Car | |||
05 president wont roll in tow mode and wont run at wot | Electric Club Car | |||
Ezgo dcs solenoid clicks but wont disengage and wont move | Electric EZGO |