lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 02-18-2012, 10:29 AM   #1
neub7
Not Yet Wild
 
Join Date: Aug 2011
Posts: 26
Default older 96 rev limiter problems

Hi, I have an early 96 C.C. I'm sure its an early model, because there is no ignitor under the rev limiter. It quits running about half the time after it gets warmed up. I have unhooked the rev limiter wires, and it still does the same thing. I've read that the coils on these are seldom the problem. I need some advice here, if the cart still acts up after unhooking the rev limiter, does that rule it out and mean it's the coil? If it is the rev limiter, does anyone have one for sale? I assume that I have to replace it with an early 96 that has no ignitor? Any info will help. Thanks.
neub7 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 02-18-2012, 10:39 AM   #2
shadowman
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: older 96 rev limiter problems

if theres no ignitor behind the limitor than its a late 96......early 96 had the ignitor behind the limitor......so your ignitor is built into the coil and theres a good chance thats your problem...........i take it when it quits you have checked for spark or lack of it? if not thats 1st and if your spark plug is good and plug wire is good than i would suggest replacing the coil/ignitor combo........................
shadowman is offline   Reply With Quote
Old 02-18-2012, 05:52 PM   #3
neub7
Not Yet Wild
 
Join Date: Aug 2011
Posts: 26
Default Re: older 96 rev limiter problems

Yes, checked and even replaced the plug just in case. Same results.
neub7 is offline   Reply With Quote
Old 02-18-2012, 06:18 PM   #4
crash12888
Gone Crazy
 
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
Default Re: older 96 rev limiter problems

Your engine is a Magneto or CDI ignition so it uses nothing to fire the coil but the flywheel.
The only thing hooked to it are things to stop fire by grounding it.
Before you buy anything disconnect everything from the coil and run it until warm. If it shuts down again then replace the coil, if it continues to run without shutting off then you have an intermittent ground in the kill circuit, maybe low oil circuit.
crash12888 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Rev Limiter Gas Yamaha
6 passanger trouble shooting. Controller problems/gas/or brake problems. Electric EZGO
Hitting the rev limiter..... problems caused? Gas Club Car
Charging Problems on older EZGO Gas EZGO
problems with older yamaha gas Gas Yamaha


All times are GMT -5. The time now is 06:01 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.