Speed controller prob.

micjager · 12-25-2007, 01:22 PM

Got a new motor and still nothing just a click from the solinoied. 96 club car 36 volt. ive checked everything . is there a way to check the speed controller?////

roady89 · 12-25-2007, 03:53 PM

Have you checked the solenoid and/or V-glide?

roady89 · 12-25-2007, 04:05 PM

Try this...this will HELP you diagnose it a little better.

1. Connect a voltmeter to B+ and M- on controller.
2. Turn key on and place F/R switch in neutral. The voltmeter should read 0 or close to zero before applying throttle.
3. Should read full battery voltage when the throttle is pressed all the way down. If not....either the throttle, solenoid, or controller is defective.

If you can verify the solenoid and throttle are functioning properly then you probably have a bad controller.

micjager · 12-25-2007, 04:34 PM

Thanks mate ill go in the carage house and try that!

micjager · 12-25-2007, 04:47 PM

Sorry there is no markings on the speed controller . There are just the three small wires and the four big motor wires.

micjager · 12-25-2007, 04:58 PM

By the way I have power to both top posts on the solinoid. I think the solenoid is in the closed position. yes?

roady89 · 12-25-2007, 05:07 PM

The controller terminal itself should have B+ and M- stamped into them. If it has a resistor across the terminals then yes you will have power across. Disconnect the resistor and you should not have power to both.

bigtlove · 07-24-2014, 09:05 AM

I have a 2010 club car precedent 48 volt battery has a full charge will start out ok go 50ft and it slow down

Stevegrmich · 07-24-2014, 09:23 AM

Quote:

Originally Posted by bigtlove

I have a 2010 club car precedent 48 volt battery has a full charge will start out ok go 50ft and it slow down

. . . go to Stickies and do the Speed Sensor Test . . .

http://www.buggiesgonewild.com/elect...nsor-test.html

scooterman · 07-24-2014, 11:50 AM

Quote:

Originally Posted by micjager

By the way I have power to both top posts on the solinoid. I think the solenoid is in the closed position. yes?

With what reference? Are you measuring negative to each?

12-25-2007, 01:22 PM	#1
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12	Speed controller prob. Got a new motor and still nothing just a click from the solinoied. 96 club car 36 volt. ive checked everything . is there a way to check the speed controller?////
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12

12-25-2007, 03:53 PM	#2
roady89 nimda Join Date: Jun 2007 Posts: 13,023	Re: Speed controller prob. Have you checked the solenoid and/or V-glide?
roady89 nimda Join Date: Jun 2007 Posts: 13,023

12-25-2007, 04:05 PM	#3
roady89 nimda Join Date: Jun 2007 Posts: 13,023	Re: Speed controller prob. Try this...this will HELP you diagnose it a little better. 1. Connect a voltmeter to B+ and M- on controller. 2. Turn key on and place F/R switch in neutral. The voltmeter should read 0 or close to zero before applying throttle. 3. Should read full battery voltage when the throttle is pressed all the way down. If not....either the throttle, solenoid, or controller is defective. If you can verify the solenoid and throttle are functioning properly then you probably have a bad controller.
roady89 nimda Join Date: Jun 2007 Posts: 13,023

12-25-2007, 04:34 PM	#4
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12	Re: Speed controller prob. Thanks mate ill go in the carage house and try that!
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12

12-25-2007, 04:47 PM	#5
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12	Re: Speed controller prob. Sorry there is no markings on the speed controller . There are just the three small wires and the four big motor wires.
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

12-25-2007, 04:58 PM	#6
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12	Re: Speed controller prob. By the way I have power to both top posts on the solinoid. I think the solenoid is in the closed position. yes?
micjager Not Yet Wild Join Date: Dec 2007 Posts: 12

12-25-2007, 05:07 PM	#7
roady89 nimda Join Date: Jun 2007 Posts: 13,023	Re: Speed controller prob. The controller terminal itself should have B+ and M- stamped into them. If it has a resistor across the terminals then yes you will have power across. Disconnect the resistor and you should not have power to both.
roady89 nimda Join Date: Jun 2007 Posts: 13,023

07-24-2014, 09:05 AM	#8
bigtlove Not Yet Wild Join Date: Jul 2014 Posts: 6	Re: Speed controller prob. I have a 2010 club car precedent 48 volt battery has a full charge will start out ok go 50ft and it slow down
bigtlove Not Yet Wild Join Date: Jul 2014 Posts: 6

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Forum
Motor and Controller	Electric Club Car
Resistor to controller	Extreme DC!
First Log: New Controller	Electric EZGO
controller	Big Block Talk!
Controller question	Electric Club Car