|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-12-2015, 12:19 PM | #1 |
Not Yet Wild
Join Date: Jun 2015
Posts: 3
|
starter will not spin with belt on
EZ-Go Workhorse 1200. was running fine, although I did notice on start-up last few times starter seemed to drag. now, starter will not turn gas engine over. I removed starter and cleaned commutator. I think brushes were ok. Put back together and bench tested and starter spins. put back on cart and will not turn the belt over. removed belt and starter spins. gas engine turns over by turning starter pulley belt manually so it is not locked up. going to do some voltage checks, but in the mean time I was looking for feedback on what to check. thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-12-2015, 12:41 PM | #2 |
Not Yet Wild
Join Date: Jun 2015
Posts: 3
|
Re: starter will not spin with belt on
I meant to add that I don't have a load tester, but voltage good at battery and headlights nice and bright.
|
06-12-2015, 07:45 PM | #3 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,193
|
Re: starter will not spin with belt on
Check for a bad connection. Are the lights still bright when you try to start it? Sounds like a battery problem to me.
|
06-13-2015, 07:49 AM | #4 |
Not Yet Wild
Join Date: Jun 2015
Posts: 3
|
Re: starter will not spin with belt on
thanks Volt_amp, lights dimmed when cranking. so I tried another battery. bad battery was culprit.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
?? How To: Change the Drive Belt & Starter Belt | Gas EZGO | |||
hit pedal and somtimes starter doesnt spin | Gas EZGO | |||
Ezgo st350 belt doesn't spin but motor does | Gas EZGO | |||
replacing alternator/starter belt with shorter belt | Gas Club Car | |||
92 carry all drive belt and starter belt | Gas Club Car |