|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
06-26-2017, 02:38 PM | #1 |
Not Yet Wild
Join Date: Jun 2017
Posts: 36
|
G2 Osillation Problem
My G2 started oscillating speeding up and down on flat or decline surface. I put new fuel pump, new carb, but didn't help. Any information would be appreciated.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-26-2017, 03:23 PM | #2 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: G2 Osillation Problem
So is it oscillating side to side or surging?
|
06-26-2017, 04:21 PM | #3 |
Not Yet Wild
Join Date: Jul 2016
Location: Kentucky
Posts: 68
|
Re: G2 Osillation Problem
is your governor disabled ?
|
06-26-2017, 06:15 PM | #4 |
Not Yet Wild
Join Date: Jun 2017
Posts: 36
|
Re: G2 Osillation Problem
|
06-26-2017, 06:16 PM | #5 |
Not Yet Wild
Join Date: Jun 2017
Posts: 36
|
Re: G2 Osillation Problem
|
06-26-2017, 06:17 PM | #6 |
Not Yet Wild
Join Date: Jun 2017
Posts: 36
|
Re: G2 Osillation Problem
It was running great with good speed then all of a sudden started shutting down then surging.
|
06-26-2017, 06:19 PM | #7 |
Not Yet Wild
Join Date: Jun 2017
Posts: 36
|
Re: G2 Osillation Problem
I can put it in neutral and open the throttle and it oscillates rpms up and down.
|
06-26-2017, 06:24 PM | #8 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: G2 Osillation Problem
You are likely hitting the rev limiter. Likely caused by a new clutch problem. Check belt width first, should be over 1 inch wide & resting at the top of the pulley on the rear clutch when cart is at rest. Then rev it up in neutral, while watching the front clutch, the belt must make it to the top of the pulley, or real close. I bet you have a broken weight in the front clutch.
|
06-26-2017, 07:16 PM | #9 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,868
|
Re: G2 Osillation Problem
Didn't see the new clutch. Sounds like a broken weight to me.
|
06-26-2017, 07:19 PM | #10 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: G2 Osillation Problem
By "new clutch problem" I meant "a problem that wasn't this bad until the weight let go", not "it's a new clutch".
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Ezgo charger problem now a cart problem | Electric EZGO | |||
Found a problem...just not THE problem. | Gas EZGO | |||
2 carts, 1 has problem, 1 has another problem. combine for one cart? | Gas EZGO | |||
Another Problem HELP! | Electric Club Car | |||
Good problem bad problem | Big Block Talk! |