09-23-2020, 03:48 AM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 11
|
99 DS Hard Start
Hello All, my first post. Picked up a 99 DS couple of months ago. All stock. I am concerned that the cart is hard to start. I have put fresh gas/filter in. Taken carb off and cleaned completely, new spark plug, new air filter, confirmed choke is working properly. Only mods are have done mods to allow it to idle while in gear/neutral. It also has a brand new battery. I just feel it should pop over quicker. It cranks and cranks for maybe 10-20 seconds. Once it starts it runs well, but is very cold blooded and needs choke or partial until it gets warmed. I plan on using it to haul firewood this winter and am concerned about it getting harder to start in colder weather. Thanks for any help.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-23-2020, 07:18 PM | #2 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,690
|
Re: 99 DS Hard Start
I’d start by adjusting the valves. This can make a huge difference.
|
09-24-2020, 04:14 AM | #3 |
Not Yet Wild
Join Date: Apr 2017
Posts: 11
|
Re: 99 DS Hard Start
|
09-25-2020, 04:05 AM | #4 |
Not Yet Wild
Join Date: Apr 2017
Posts: 11
|
Re: 99 DS Hard Start
So, update. I pulled valve cover and lo and behold, I have non adjustable valves! They are obviously the hydraulic lifter type. So no go there. Than move on to leak down test. Had motor at TDC on compression stroke, but couldn't get the motor to stay locked and when I put air to it, it kept trying to rotate no matter what I did. Than on to a compression test. I have 150 PSI, which I consider pretty good. And I realized that my starting procedure wasn't working. I was putting the gas peddle to the floor. It starts much better if I push the peddle just enough to get the motor turning and a little choke and it fires right off. Tempermental old girl....
|
09-26-2020, 01:54 PM | #5 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,690
|
Re: 99 DS Hard Start
A couple things...
Someone must have swapped the FE290 for a FE350. I’ve never seen a 290 with HLA’s but most club car 350’s had them. Secondly, if feathering the gas pedal makes it better then your cable linkage is out of adjustment. Remove the cover to the back electrical box next to the air filter. There’s a cable with a couple 10mm nuts on it. With the key and cart OFF slowly depress the go pedal with your hand. You should hear/see the microswitches click and the carb NOT move. After you press the gas pedal another 1/2” or so further you should start to see the cable at the carb juuuust barely begin to move. Use those 10mm nuts to adjust the cable going into the black box until it does this like stated above. If the carb begins to open too soon, it will cause harder starting and can cause jerky low speed operation as well. |
09-28-2020, 03:14 AM | #6 | |
Not Yet Wild
Join Date: Apr 2017
Posts: 11
|
Re: 99 DS Hard Start
Quote:
|
|
03-26-2021, 12:09 AM | #7 |
Not Yet Wild
Join Date: Mar 2021
Posts: 2
|
Re: 99 DS Hard Start
I had same on my 93 DS and did the rookie move to r/r carb, filters, pump, plug, then blow out fuel pick up line and add air in the tires for safe and completely irrelevant measures.
Now she starts okay but have to pump the pedal and no idle. She seems to run hot. If I choke it she dies so air is not the issue. I've adjusted the mixture screw and it doesn't seem to help. Also adjusted the idle set screw, also no real help. Won't idle. I can run it but it wants to die. |
03-29-2021, 08:35 PM | #8 |
Not Yet Wild
Join Date: Jul 2016
Location: Lake Wynonah, Pa
Posts: 23
|
Re: 99 DS Hard Start
My 2001 DS was hard starting for quite a while. It finally died on me the other day and i swapped out the coil. It now starts quicker than it ever has. I guess i had weak spark.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2017 Club Car Precedent with EFI motor - hard start/difficult start. | Gas Club Car | |||
Hard start | Gas Club Car | |||
G-1 hard start | Gas Yamaha | |||
Hard to Start | Big Block Talk! | |||
Hard Start | Gas Club Car |