|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-05-2013, 11:22 AM | #1 |
Not Yet Wild
Join Date: Oct 2013
Location: North Vernon, in
Posts: 4
|
2006 ezgo seems stuck in lower gear
My 2006 ezgo ran great till last night. Now it sounds and runs like it is in a very low gear. Engine winds out quick and won't run very fast at all. Maybe 5 mph instead of 15-16 mph. Thanks for any help.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-07-2013, 09:31 AM | #2 |
Not Yet Wild
Join Date: Oct 2013
Location: North Vernon, in
Posts: 4
|
Re: 2006 ezgo seems stuck in lower gear
I raised the read end off the ground and pressed accelerater. The clutch moved what seems to be all the way in. Both rear wheels move in forward or reverse. I can turn both wheels by hand with no difficulty each direction. I'll keep researching for more info on here but welcome any suggestions and help. Thanks
|
10-07-2013, 03:43 PM | #3 |
Getting Wild
Join Date: Apr 2013
Location: N.E. Louisiana
Posts: 78
|
Re: 2006 ezgo seems stuck in lower gear
Is your driven clutch Opening Up , Your Drive clutch will close But the driven clutch will open up to let your belt go down for more speed , could be it is Stuck or Gone Ca-poop . Drive Clutch is Front Clutch & Driven Clutch is Back Clutch.
|
10-07-2013, 04:22 PM | #4 |
Not Yet Wild
Join Date: Oct 2013
Location: North Vernon, in
Posts: 4
|
Re: 2006 ezgo seems stuck in lower gear
The driven clutch is not opening up. Is there a way to get it un-stuck? Also, can worn belt cause it not to open up? Thanks for replying and helping.
|
10-08-2013, 11:03 AM | #5 |
Not Yet Wild
Join Date: Oct 2013
Location: North Vernon, in
Posts: 4
|
Re: 2006 ezgo seems stuck in lower gear
I tried new belt. no luck. Sprayed lubricant on shaft where pulley opens up and was able to pry opens a little. Belt drops down about 1/2 inch. Hopefully clutch was just stuck and I'll be able to open further after a while.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
ezgo stuck in gear will not shift | Gas EZGO | |||
'06 Gas TXT stuck in low gear-slow speed | Gas EZGO | |||
G22 Clutch stuck in high gear | Gas Yamaha | |||
High torque motor vs. Lower rear gear | Electric Club Car | |||
Adjustment Of Governor/Linkage to help with lower gear/torque? | Gas EZGO |