|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-05-2014, 02:05 PM | #1 |
Getting Wild
Join Date: Nov 2008
Location: Louisville Ky.
Posts: 99
|
Yamaha G1 2 stroke, won't run with air filter on.
Ok, I'm sure I'll figure this out, but in the meantime, I figure I'll post it and see if any of you guys have eve had this happen. Cart will not run with any type of filter on the carb. I tried the factory one, even took it off and sucked through it to see if it was clogged, and it's as free flowing as they come. Next, I took a brand new motorcycle air filter, and rigged it on the carb, still, no bueno! With no filter on, it runs like a champ, but it runs best with the mixture screw about 1/2 turn out. New fuel filter, all lines good, carb has been cleaned. Any ideas? I did notice that the float needle does not have a clip that holds it on to the float. Not sure if this is normal for these carts or not. BTW, I just got this cart a couple days ago, and it's been sitting for a few years at least. Compression is 135! Thanks
Sent from my iPhone using Tapatalk |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-05-2014, 06:46 PM | #2 |
Gone Wild
Join Date: Aug 2007
Location: North Texas
Posts: 2,312
|
Re: Yamaha G1 2 stroke, won't run with air filter on.
Check the main jet!
|
07-06-2014, 09:03 AM | #3 |
Getting Wild
Join Date: Mar 2013
Location: Charlotte, NC & Murrells Inlet, SC
Posts: 110
|
Re: Yamaha G1 2 stroke, won't run with air filter on.
You must have a clog in your carburetor somewhere. As tew45 says above, I would start with the main jet and be sure it's absolutely clear. However, I would also check the pilot jet to be sure it's not clogged either. As you clean the jets, be gentle with them as you don't want to enlarge the holes.
|
07-06-2014, 09:18 AM | #4 |
Gone Wild
Join Date: Oct 2010
Posts: 6,730
|
Re: Yamaha G1 2 stroke, won't run with air filter on.
Check for a crack in the rubber carb flange.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Air Filter for 93 2 Stroke Par Car | Gas Columbia ParCar | |||
Yamaha G14 pre filter | Gas Yamaha | |||
Yamaha G-9 air filter | Gas Yamaha | |||
remote oil filter for marathon 4 stroke? | Gas EZGO |