G9 4 stroke electric problems

[bhunterp]

No power on the switch. Can jump the solenoid and motor will turn over but not getting spark from spark plug.

Sent from my SAMSUNG-SM-G930A using Tapatalk

[sho305]

Check the pedal switch, it can be bypassed to test it. The power goes to key, then pedal, then fires up starter and ignition. Key does not go out very often. Also check other connections and battery cables, etc. Connection bad is common.

[bhunterp]

Originally Posted by sho305

Check the pedal switch, it can be bypassed to test it. The power goes to key, then pedal, then fires up starter and ignition. Key does not go out very often. Also check other connections and battery cables, etc. Connection bad is common.

Yeah the pedal is opening and closing when I ohm it. I thought that was my problem. When I seen it acting right I checked voltage and had nothing on the key or the wires going to pedal. So I've got another solenoid i m gonna try tomarrow

Sent from my SAMSUNG-SM-G930A using Tapatalk

[sho305]

If the wire is not hot, you have a power issue trace it back I think it hooks on through the fuse and to the generator or battery. If you do and solenoid not working try bumping tapping it some, when mine went out I could stomp on the floor in front of it and cart would start. They are not cheap but last near forever. You can't use a car solenoid its not constant duty. Make sure you check all wires before you buy something, very common to have wire connection issues. Some grounds are wired also check those, you will see 12v there but it wont work because the ground is corroded/bad connection. If you test 12v to that ground you will see nothing.

[bhunterp]

Found out it was a grounding issue. The motor wasn't grounded. So I ran a jumper from ground to motor. Another to key switch

Originally Posted by sho305

If the wire is not hot, you have a power issue trace it back I think it hooks on through the fuse and to the generator or battery. If you do and solenoid not working try bumping tapping it some, when mine went out I could stomp on the floor in front of it and cart would start. They are not cheap but last near forever. You can't use a car solenoid its not constant duty. Make sure you check all wires before you buy something, very common to have wire connection issues. Some grounds are wired also check those, you will see 12v there but it wont work because the ground is corroded/bad connection. If you test 12v to that ground you will see nothing.

Sent from my SAMSUNG-SM-G930A using Tapatalk