|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-07-2021, 10:06 AM | #1 |
Not Yet Wild
Join Date: Mar 2020
Posts: 1
|
CC Precedent- dies then restarts after choking
Hi all.. got a 2004 Precedent that runs fine for about 5 minutes.. then acts as if someone turned the fuel off.. just stalls and cranks over.. depress the choke and it fires back up and runs for a few minutes and problem repeats.. new carb, same issue.. fuel pump possibly?
Seems like fuel lines empty when this happens as well.. tank venting fine too.. acts as if only running on fuel in bowl of carb.. any ideas? Thanks!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-07-2021, 10:36 AM | #2 |
Gone Wild
Join Date: Dec 2017
Location: Montreal, Quebec, Canada
Posts: 1,130
|
Re: CC Precedent- dies then restarts after choking
clogged fuel filter maybe?
|
02-07-2021, 11:24 AM | #3 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: CC Precedent- dies then restarts after choking
Make sure the pulse line from the engine to the fuel pump doesn't have a "droop" to it. If it droops down the low spot can fill with oil and interfere with the vacuum / pressure pulse to the fuel pump. Also, check that the air vent on the fuel pump doesn't get plugged up with dirt and grease. Needs to breath for the diaphragm in the pump to work.
|
02-07-2021, 02:40 PM | #4 |
Gone Wild
Join Date: Jul 2012
Location: maryland
Posts: 818
|
Re: CC Precedent- dies then restarts after choking
I worked on one with this exact same thing happening and it ended up being a clog in the pickup tube. I pulled the tube, blew compressed air through it and put it back. Ran like a charm after.
|
02-07-2021, 03:19 PM | #5 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: CC Precedent- dies then restarts after choking
Seen that when to gas gasket inside the gas cap gets torn. Little chunks of rubber sitting in the tank can get sucked up in the pickup tube.
|
02-07-2021, 03:55 PM | #6 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,625
|
Re: CC Precedent- dies then restarts after choking
Also could be a weak or crappy fuel pump if it’s aftermarket. Only use a genuine mikuni fuel pump the rest are junk
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Bad Boy MTV Electric shuts down and restarts on pedal release | Electric golf carts | |||
Precedent jerks, dies, let it sit goes again? | Electric Club Car | |||
48V precedent bucks and dies | Electric Club Car | |||
'95 model cuts out and restarts while driving | Gas Club Car | |||
93 Gas..Runs good, then won't restart, wait a while and restarts | Gas Club Car |