|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-21-2009, 08:09 AM | #1 |
Not Yet Wild
Join Date: Oct 2009
Posts: 5
|
96 gas ezgo wont turn over
Hey Gang,
I have a 96 gas ezgo and was driving it the other day and just stopped runing , i put new Solenoid in no mas. When i remove the wire that comes from the accelorator micro switch and check i have 12.64 volts but when i install back on solenoid no volts with. I also disconnected every wire that was attached to silenoid and left micro switch wire hooked up still no volts. i am thinking bad micro any suggestions oh hey and when i jump from the pos side of battery to solenoid it will run all day. In His Grips ,Scot |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-21-2009, 08:13 AM | #2 | |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: 96 gas ezgo wont turn over
Quote:
Good luck |
|
10-21-2009, 08:17 AM | #3 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: 96 gas ezgo wont turn over
Pull the two wires off of the micro and jumper them together. That should tell you if it is the culprit.
I was just looking for the wiring diagram for your cart and couldn't find it, someone will chime in or post it. Welcome Scot to BGW!!! |
10-21-2009, 08:25 AM | #4 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: 96 gas ezgo wont turn over
|
10-21-2009, 08:27 AM | #5 |
Gone Crazy
Join Date: Jun 2008
Location: Mississippi
Posts: 2,183
|
Re: 96 gas ezgo wont turn over
To BGW
|
10-21-2009, 06:32 PM | #6 |
Not Yet Wild
Join Date: Oct 2009
Posts: 5
|
Re: 96 gas ezgo wont turn over
ok so i pulled wires off the micro switch and jumpered them nothing, i check pwr wires green and red thru cable at both ends and their is no short in each wire. I even check key switch again still good i am confused help
In His Grips, Scot |
10-21-2009, 08:36 PM | #7 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: 96 gas ezgo wont turn over
Ok, so who can post up a pic of the wiring diagram?
I searched for it and only found 91 and back. |
10-21-2009, 11:15 PM | #8 |
It ain't gonna be easy.
Join Date: Apr 2008
Location: St. George, SC
Posts: 1,480
|
Re: 96 gas ezgo wont turn over
This is from the service guide and while it is for a later year, it should help at least trouble shoot the problem.
|
10-22-2009, 01:34 AM | #9 |
Not Yet Wild
Join Date: Oct 2009
Posts: 14
|
Re: 96 gas ezgo wont turn over
check that 7amp fuse I had the same problem today with my 88 ezgo and found a wire has shorted out and blew the fuse.
|
10-22-2009, 07:09 AM | #10 |
Not Yet Wild
Join Date: Oct 2009
Posts: 5
|
Re: 96 gas ezgo wont turn over
First i just want to thank everyone for all your help, and yes i did check fuse looked good but i still replaced it . i am going to get a new accel micro today and put in, even i dont feel thats the real problem. I do have a question i am only getting 8.45 volt to the blue wire that comes from the key switch ( I even jumped out Key switch ) no mas this is getting the best of me its become a personal war between me and my cart.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G-1 wont turn over | Gas Yamaha | |||
yamaha cart wont turn over | Gas Yamaha | |||
ezgo starter generator wont charge battery but will turn motor | Gas EZGO | |||
Wont turn left and now wont turn right | Electric EZGO | |||
Wont Turn Over No Spark | Gas Yamaha |