06-01-2012, 04:45 PM | #1 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
1975 ezgo 2stroke
This cart ran before, but now it wont rev up enough to engage the clutch. Cleaned the carb. Drained old gas and mixed new with oil as specified. Trying to get it running for parade. air screw is set at 3/4 turn. We are about 850 feet above sea level. thanks for any help.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-01-2012, 04:46 PM | #2 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
Re: 1975 ezgo 2stroke
also new plugs and gas lines.
|
06-01-2012, 04:47 PM | #3 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
Re: 1975 ezgo 2stroke
has really good spark
|
06-01-2012, 05:39 PM | #4 |
Not Yet Wild
Join Date: May 2012
Location: Central Wisconsin
Posts: 33
|
Re: 1975 ezgo 2stroke
CertInly sounds like its not getting fuel. I'm not a carb professional but Snds like a stuck needle valve to me...??
|
06-01-2012, 05:42 PM | #5 |
Not Yet Wild
Join Date: May 2012
Location: Central Wisconsin
Posts: 33
|
Re: 1975 ezgo 2stroke
Cracked fuel lines on that old of machine wud b common n happened to me. Wud run a lil then quit. Found a crack on backside of fuel line after tearing apart fuel pump n finding it was fine.
|
06-01-2012, 08:56 PM | #6 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: 1975 ezgo 2stroke
When you say you cleaned the carburetor did you take it down to the last nut and bolt, remove the jets and nozzles and clean out the orifices?
Why don't you take the fuel line off the carburetor and point it into a jar then crank the engine. You should see a large pulsing jet of fuel. Let us know what happens. Dave |
06-02-2012, 10:43 PM | #7 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
Re: 1975 ezgo 2stroke
thanks for reply guys. Yea, I took carb complety apart. Took jets and needles out, check to see if they were plug, blew air threw orffices and reassembled. Took gas line of carb and turned engine over and gas game up threw line.
|
06-02-2012, 10:45 PM | #8 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
Re: 1975 ezgo 2stroke
I even squirted starting fluid into carb when trying to start and didnt make a difference
|
06-03-2012, 09:28 AM | #9 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: 1975 ezgo 2stroke
OK, let's try checking the seals: Jack up the cart or pull the drive belt so You don't run anything over if it *does* fire up ... Now, while turning it over normally, spray some wd40 or carb cleaner at the rear of the motor where the crankshaft exits the engine, then, try it again while spraying directly into the fan on the front of the motor. If either of these actions result in a change in RPM's, then thast corresponding seal needs to be replaced.
(an easier test but not as accurate is to start it in reverse - 8 times or so out of 10 if the seals are going but not *gone*, the cart will still run reasonably well backwards - at least better than it does in forward ...) |
06-03-2012, 10:25 PM | #10 |
Not Yet Wild
Join Date: Apr 2012
Location: seattle, wa
Posts: 44
|
Re: 1975 ezgo 2stroke
opkay, pulled of fuel pump. line going from fuel pump to crankcase had hole where it rubbed. replaced it and tried again. nothing. it acutaly tried to run and thats it. I keep thinking fuel. Like i said took carb off and cleaned. pulled jets and needels out and blue orrfice out. hopefully the lines went back correctly on fuel pump. one line on top goes to engine, one on bottom goes to fuel tank and other one one bottom goes to carb.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
ezgo stuff- 2stroke | Golf Carts and Parts | |||
1975 EZGO moves on it's own | Electric EZGO | |||
oil chang help for my 91 ezgo 2stroke!! | Gas EZGO | |||
ezgo s/n 1975-1979 | Gas EZGO | |||
EZGO 2stroke clutch | Gas EZGO |