07-09-2014, 07:26 PM | #1 |
Not Yet Wild
Join Date: Apr 2012
Posts: 14
|
1993 Club Car Issue
My 1993 Gas Club Car is having issues that just started... it will run good then seems like it is starving for gas... cuts in and out and sounds like chitty chitty bang bang.... later it will run fine for a block... then more starving for gas...
so far we have drained the gas and put in new gas... new fuel filter... new air filter... new spark plug... pulled the carb and clean it (3 times)... I am ready to move into the ignition and micro switches... any ideas as to what is wrong? if it is ignition and/or micro-switches, any recommendations on where to buy them? thanks for your time |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-10-2014, 09:02 PM | #2 |
Getting Wild
Join Date: Jun 2013
Location: Capac, Michigan
Posts: 108
|
Re: 1993 Club Car Issue
I have kinda gone thru the same issues with my 93 gasser. You can read my post here a few weeks back. I went thru and replaced the fuel system parts..no help. I just replaced the coil and igniter...no help. I finally removed the ground wire from the rev limiter and so far for a week now have had no further issues. Just have to be careful as it will not cut out when reaching the set RPM's. But when I look back everytime mine died on me it was just like trying to go too fast and the rev limiter saying no. Give it a try first before replacing the ignition parts and see if it helps. Unfortunately the price on the rev limiter is over $100 so it may not get replaced for me. Good luck and let us know what you find....
|
07-10-2014, 09:11 PM | #3 |
Not Yet Wild
Join Date: Apr 2012
Posts: 14
|
Re: 1993 Club Car Issue
thanks for the idea - I will get to it when I get back to the lake next weekend
|
07-11-2014, 10:04 AM | #4 |
Not Yet Wild
Join Date: Apr 2010
Location: Brookfield Il
Posts: 5
|
Re: 1993 Club Car Issue
Where is the rev limiter located?
|
07-12-2014, 09:35 AM | #5 |
Getting Wild
Join Date: Jun 2013
Location: Capac, Michigan
Posts: 108
|
Re: 1993 Club Car Issue
lift the seat off and it's right on the front of the engine near the bottom..easier to do with the rear body removed but can be done otherwise...all that needs to be done is remove the ground wire..10mm bolt then make sure the ground doesnt touch anything..
|
07-12-2014, 10:08 AM | #6 |
Getting Wild
Join Date: Jun 2013
Location: Capac, Michigan
Posts: 108
|
Re: 1993 Club Car Issue
just be aware your RPM's are not limited with the ground removed...could be hazardous to the health of your engine....
|
07-14-2014, 08:11 AM | #7 |
Not Yet Wild
Join Date: Apr 2010
Location: Brookfield Il
Posts: 5
|
Re: 1993 Club Car Issue
Thanks I will check it out.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1993 Club Car DS - Govenor or Rev-Limiter Setting/Issue | Gas Club Car | |||
Wiring Issue - 1993 Electic Club Car | Electric Club Car | |||
New 1993 club car 36v | Electric Club Car | |||
1993 club car will not go | Electric Club Car | |||
1993 TXT carb issue | Gas EZGO |