|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
01-12-2011, 06:39 PM | #1 |
Getting Wild
Join Date: Aug 2010
Location: PA
Posts: 138
|
G16 cold start problem
This occurs only when temps are below freezing. My G16 acts like its not getting enough fuel. I have to spray a small spirt of start fluid to get it to run. It runs for a few seconds and dies. Then after many cranks choke closed and open action and brief starts it will slowly start to stay running. Once its warmed up everything is fine. I think it might be a weak fuel pump, vacuum leak to the fuel pump, or a dirty fuel filter. Its below 20 degs out there right now. To cold to be taking things apart. So I posted this to get input and further idea's. Plus I'm bored silly being stuck in doors all day with this weather. So all you cart gear heads out there lets hear some technical trouble shooting
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-12-2011, 08:03 PM | #2 |
Getting Wild
Join Date: Nov 2010
Location: florida
Posts: 89
|
Re: G16 cold start problem
always check compression ....if its low wont start on cold conditionds
|
01-12-2011, 08:35 PM | #3 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: G16 cold start problem
put a big block in it like mine :) its awesome and starts every time....good luck though
<<<<<<<< |
01-13-2011, 07:03 AM | #4 |
Getting Wild
Join Date: Aug 2010
Location: PA
Posts: 138
|
Re: G16 cold start problem
|
01-13-2011, 08:02 AM | #5 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,871
|
Re: G16 cold start problem
G16's are cold collared as crap. My 99 used to aggrivate me to no end. Totally different from my G9 or G2 which would almost start without using the choke in zero temp weather. The only other cart I've owned that was more cold collared was a 05 Ezgo St350.
|
|
|
01-13-2011, 10:46 AM | #6 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: G16 cold start problem
OK I know I preach about clean carbs all the time, when
the temps drop and the cart spins a little slower you lose the vacuum signal if there is any obstruction in the pilot jet system. |
|
|
Similar Threads | ||||
Thread | Forum | |||
ez go gas cold start 9 hp | Gas EZGO | |||
Hard to start in Cold weather | Gas EZGO | |||
G9 Hard to start when this cold | Gas Yamaha | |||
97 gas EZGO will not start if cold | Gas EZGO | |||
G2 Cold Start Finally Fixed | Gas Yamaha |