lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 11-03-2009, 10:20 PM   #1
mjrowley
Gone Wild
 
Join Date: Aug 2009
Posts: 179
Default I need to change the rear axle - rear end oil

I found info on this at the following site.

http://www.golfcarthotrod.com/91/how...car-golf-cart/


"Club Cart golf carts need the rear axle / rear end oil changed periodically. Here is how you do it.


1: Take your golf cart out for a spin for about 15 minutes to warm up the oil for faster draining.

2: Park your golf cart on a level surface. Put an oil pan under the cart’s rearend. Ether use a 14mm socket or wrench to remove the rearend drain plug (see pic). You can use a jack on the opposite side to tilt the rearend up enough to make sure you get all the oil drained. If you have a pump with hose you can get even more oil out.

3: After draining the oil, replace drain plug and take out the fill plug. You can use a oil pump to fill it back if you have one. If no you can use a funnel and small hose. Your tubing should fit loosely in the hole so that air move around it while filling. You can remove the panel behind the seat and drop the oil tubing down to fill the rearend with oil. The manual calls for SAE 30w oil. You can use a heavier weight gear oil for added protection but the manufacturer says 30w it the way to go.

4: Fill the rearend with oil until it starts to run back out of the hole. When you reach that point you are full.

5: Reinstall the filler plug and clean off any oil that leaked around the rearend. Your Done"



So is that good info?

How many quarts does it take?
mjrowley is offline   Reply With Quote
 
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
CC 88 DS Gas Rear Axle Gas Club Car
2 sp quick change rear ends Gas Yamaha
Rear diff oil change Electric EZGO
89 Engine and rear oil change Gas Club Car
02 TXT rear end oil change ??? Gas EZGO


All times are GMT -5. The time now is 02:34 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.