|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-12-2010, 11:27 AM | #1 |
Not Yet Wild
Join Date: Oct 2010
Posts: 1
|
1987 Club Car only runs at top speed
I checked continuity for all micro switches. I found one that was bad. I replaced it with the F&R switch, bypassed the F&R switch with a wire and still have the problem.
While in neutral, l pressed the accelerator pedal slowly and heard each selodoid click begining with the first one on the driver side. Bill |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-12-2010, 01:18 PM | #2 |
Gone Wild
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
|
Re: 1987 Club Car only runs at top speed
On older carts like yours, even though the solenoids click does not mean they are making internal contact? Check that each one is feeding power through to coils in order?Also resistor coils and connections on board are bad for poor connections so check all for loose, cracked connections.
|
10-13-2010, 06:38 AM | #3 |
Gone Wild
Join Date: Feb 2009
Location: Not sure yet
Posts: 500
|
Re: 1987 Club Car only runs at top speed
Does it take off at top speed right from the start? or does it click thru the first 4 solenoids first, then run like a bat out of hell?
|
04-25-2012, 05:23 PM | #4 |
Not Yet Wild
Join Date: Apr 2012
Posts: 2
|
Re: 1987 Club Car only runs at top speed
I would like to get in on this one! My 85 36v club car goes through all four and then finally runs on the last only! What's with that?
|
04-26-2012, 12:23 AM | #5 |
Not Yet Wild
Join Date: Dec 2011
Location: Peachtree City, GA
Posts: 28
|
Re: 1987 Club Car only runs at top speed
I had a similar issue on my 87, except I was missing 1st speed. I swapped out the 1st speed solenoid with one of the other ones but it still didn't work. Turned out it was the microswitch that was bad, so I just replaced the whole assembly. I have since replaced all 5 solenoids, all 3 resistors, the resistor brackets and the buss bar. Now it runs like a champ and has a little more pep too!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1985 G1 Runs fine low speed , high speed run for a mile then fall on its face | Gas Yamaha | |||
2002 CC DS runs at half speed | Electric Club Car | |||
82 Club car only runs at full speed | Electric Club Car | |||
1987 wire diagram insde speed box? | Electric Club Car | |||
1987 Club Car Speed Switch Assembly | Electric Club Car |