lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 08-11-2018, 11:39 PM   #1
derekmc26
Not Yet Wild
 
Join Date: Aug 2018
Posts: 2
Default Got a problem

First off it's a 94 clubcar ds. My aunt got it and her husband couldn't get it started so they told me I could have it. It looks like it was in a flood. It turns over but won't crank, replaced fuel lines cleaned carb cleaned gas tank new battery motor sounds strong. Any ideas?

Sent from my Moto E (4) using Tapatalk
derekmc26 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 08-12-2018, 09:41 AM   #2
BBBHC
Gone Wild
 
BBBHC's Avatar
Club Car
 
Join Date: Jul 2018
Location: Central Ohio
Posts: 1,713
Default Re: Got a problem

Maybe check your gap on your spark plug?
BBBHC is offline   Reply With Quote
Old 08-13-2018, 10:48 PM   #3
derekmc26
Not Yet Wild
 
Join Date: Aug 2018
Posts: 2
Default Re: Got a problem

All that is good what kind of damage will water do to your generator?

Sent from my Moto E (4) using Tapatalk
derekmc26 is offline   Reply With Quote
Old 08-14-2018, 04:05 PM   #4
Fairtax4me
Bonafide Nincompoop
 
Fairtax4me's Avatar
Club Car
 
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,311
Default Re: Got a problem

What makes you think it was flooded? Is there water in the crankcase?

Water could ruin the bearings in the starter, and might make the brushes stick in the holders if they rust. Other than that there isn't anything to hurt really. If you suspect it got water in it, pop the rubber covers off the brush end and see how it looks. If it's wet leave the covers off and let it dry out. Spray some electrical contact cleaner on the brushes and use compressed air to dry them. You don't have to have compressed air, but it'll help.


If it's cranking don't worry too much about the starter/generator for now.

Check for spark with a spare spark plug grounded to the block.
Remove the carburetor and clean it out. Disassemble the entire thing and clean all of the ports, the pilot jet, main jet, and the air bleed tube in the center.

Make sure the fuel pump is pumping fuel when the engine is cranking.
Fairtax4me is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Ezgo charger problem now a cart problem Electric EZGO
Found a problem...just not THE problem. Gas EZGO
2 carts, 1 has problem, 1 has another problem. combine for one cart? Gas EZGO
Another 03 CC Problem Electric Club Car
Good problem bad problem Big Block Talk!


All times are GMT -5. The time now is 03:30 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.