|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-04-2022, 03:17 PM | #11 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 2012 Tempo Sparks and Smoke
Blue wire is supply to a voltage reducer to power lights, radio, etc. If you don't have a reducer you should get one.
Flip the Tow/Run switch back to Run. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-04-2022, 03:22 PM | #12 | |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
Quote:
a + symbol under it and the red wire from 48v + pack is on the other. Only thing I had to do was install the resistor. Are the resistors directional? |
|
10-04-2022, 03:25 PM | #13 | |
Gone Wild
Join Date: Sep 2022
Location: Minnesota
Posts: 1,289
|
Re: 2012 Tempo Sparks and Smoke
Quote:
|
|
10-04-2022, 03:37 PM | #14 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
|
10-04-2022, 03:43 PM | #15 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
Both of these fuses checked good.
This is how it was wired before the new parts were installed. Went back with same parts except he supplied a 350a controller to replace the 250a |
10-04-2022, 04:00 PM | #16 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
Battery Pack 49.7 volts sitting and when key is on and accelerator pedal pushed no change.
Checked voltage at solenoid... Red side 49.7 volts... Yellow side 49.1 volts with key off and in run position. Throttle sensor? This motor has a regenerative braking I think? he said it felt like the brakes were on after he shorted the motor. Just trying to help him get back going but as y'all know I do not like electric carts. I would much rather have gas |
10-04-2022, 06:44 PM | #17 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
Ok did some more testing have pack voltage at 2 little terminals on solenoid when gas pedal is pressed.
When I hooked up ground to pack and turned on tow/run and put in reverse it took a min for the buzzer to start buzzing??? Could that be a sign of a problem? Thinking MCOR maybe? Solenoid is not clicking |
10-04-2022, 07:02 PM | #18 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 2012 Tempo Sparks and Smoke
Is the connector on the controller plugged in all the way? Can’t really tell from the pic but it doesn’t look pushed in far enough.
|
10-04-2022, 07:21 PM | #19 |
Gone Wild
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
|
Re: 2012 Tempo Sparks and Smoke
|
10-05-2022, 06:53 AM | #20 |
Gone Wild
Join Date: Sep 2022
Location: Minnesota
Posts: 1,289
|
Re: 2012 Tempo Sparks and Smoke
Just looking to maker sure we have a clear update in one post here and the current things that are working not working.
Replaced items -Motor Solenoid and resistor -Controller Things that work -Lights -Horn -Rev Buzzer Things that DONT' work -Drive forward or Reverse |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Club Car Tempo Will not Move Forward or Reverse After Sparks from rear motor connect | Electric Club Car | |||
Sparks and smoke from starter generator | Gas EZGO | |||
Tempo vs Onward | Electric Club Car | |||
'84 Marathon "smoke test" - NO SMOKE, but questions | Electric EZGO | |||
Sparks and Smoke | Electric Club Car |