|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-24-2014, 06:31 PM | #1 |
Not Yet Wild
Join Date: Jan 2014
Posts: 5
|
Club Car throttle issue under load
So i just got my first gas club car. It's a 96 model with the fe350 and has been recently rebuilt and runs great. I was just tinkering with the steps to speed it up under the "sticky" section.
I first lengthened the rod for the throttle and got the linkage set right to where it would start properly etc.. , it didnt make a significant difference. Next i loosened the governer clamp without doing the tie-wrap around the spring yet.. and it maybe made a "small" difference. Then i did the tie-wrap in maintenance mode and got it to hit the rev limiter, so i figured i'd take it for a spin. It ran at a very low rpm under driving conditions and wasn't fast at all, put it back in maintenance mode and it goes all the way up to the limiter and revs high, drove it again and the same low rpm crawl. I cut the tie wrap and it went back up to the speed it was at but still no real significant gain from stock. All i have done so far is made sure the air filter was clean and made sure the throttle linkage adjustment didnt affect the parking brake and it hasn't.. any suggestions?? just wanted to wake this thing up a little. |
|
|
Similar Threads | ||||
Thread | Forum | |||
ezgo 36v throttle issue | Electric EZGO | |||
Throttle issue? | Electric Club Car | |||
full throttle issue | Electric Club Car | |||
1989 par car throttle issue | Gas Columbia ParCar | |||
EZGo Marathon throttle issue | Electric EZGO |