|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-15-2020, 11:22 PM | #1 |
Not Yet Wild
Join Date: Jun 2020
Posts: 4
|
05 txt/pds 1-3 beeps in diagnostic mode. Help please 🙏
I have a 05 ezgo 36v txt-pds with the f&r switch on the dash. New batteries, battery cables, solenoid and speed sensor have been replaced.
When giving throttle its slightly jerky but take off and runs fine until 3/4 throttle and motor cuts out. Cart goes into limp mode after that and will only run 5mph max. In diagnostic mode im getting the 1 beep followed by 3 beeps. I've already replaced speed sensor to no avail. When it says magnet/torque on the diagnostic sheet what is that referring to? Anyone have any ideas on What it could be? Also I've checked voltage when driving and batteries do not drop voltage to indicate bad battery. To me it feels like when you're driving and once you reach a certain amperage the controls goes into limp mode to protect its self. That's the best way i can describe it. Thanks for any and all help. Also.. also..lol. I bought it not running with dead batteries so I don't know if it was doing this before batteries where replaced. It had been sitting for several years outside. I did take the controller out and opened it up to make sure it didn't have any moisture damage/ corrosion inside. Everything looked clean and dry. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-16-2020, 11:00 AM | #2 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 05 txt/pds 1-3 beeps in diagnostic mode. Help please 🙏
The magnet disk is attached to the motor's armature shaft with a screw. If the screw get loose, the magnet disk slips instead of turning at the same RPM as the armature.
Remove the speed sensor and tighten the screw. Make sure both snap rings (item 28 ) are in place, proper spacing between the magnet disk and speed sensor is critical. |
06-16-2020, 11:05 AM | #3 | |
Not Yet Wild
Join Date: Jun 2020
Posts: 4
|
Re: 05 txt/pds 1-3 beeps in diagnostic mode. Help please 🙏
Quote:
Thanks for the reply. Ill try this when I get home from work this evening. |
|
06-17-2020, 07:29 PM | #4 |
Not Yet Wild
Join Date: Jun 2020
Posts: 4
|
Re: 05 txt/pds 1-3 beeps in diagnostic mode. Help please 🙏
Thats exactly what it was. Thank you for the help.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2016 TXT48 Diagnostic Mode? | Electric EZGO | |||
ezgo pds beeps and beeps | Electric EZGO | |||
🙏After Market Wheels for 3 wheel 85 marathon 36v | Electric EZGO | |||
PDS won't go into Diagnostic | Electric EZGO | |||
No beeps during speed chip diagnostic | Electric EZGO |