lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 05-18-2010, 10:54 AM   #1
treadhead
Not Yet Wild
 
Join Date: May 2010
Posts: 9
Default how to check the motor

How do i check the motor?If i feed voltage to my large terminals one at a time on the motor all it does is spark at the jumper cable and only jerks the tire. Thats it.How do I check the motor for operation.How do i check the solenoids for operation?
treadhead is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 05-18-2010, 11:08 AM   #2
roady89
nimda
Club Car
 
Join Date: Jun 2007
Posts: 13,022
Default Re: how to check the motor

SEPEX motor check


  • Turn off, remove key, jack up car so rear wheels are off ground.
  • Remove all cabling from motor. Mark where each cable was connected to motor.
  • With a jumper connect A1 to F1
  • With a jumper connect A2 to F2
  • Supply power to the A terminals.(6-12 volts should be fine)
  • Use at your own risk. A small spark is expected each time you make/break the connection. Dont forget to jack the cart up and get the rear wheels off the ground. Make sure the brake is off.


Series motor check


  • Turn off, remove key, jack up car so rear wheels are off ground.
  • Remove all cabling from motor. Mark where each cable was connected to motor.
  • With a jumper connect S1 to A2.
  • Supply power to the A1 and S2 terminals.(6-12 volts should be fine)
  • Use at your own risk. A small spark is expected each time you make/break the connection. Dont forget to jack the cart up and get the rear wheels off the ground. Make sure the brake is off.


Solenoid Check


  • Disconnect both large and small wires from solenoid
  • Supply pack voltage to the small terminals. Should click
  • With a volt/ohm meter check the large terminals for continuity. Just because it clicks doesn't mean its good
roady89 is offline   Reply With Quote
Old 05-18-2010, 01:46 PM   #3
treadhead
Not Yet Wild
 
Join Date: May 2010
Posts: 9
Default Re: how to check the motor

Thanks for the help i will check them in a few minutes.When i bought the cart it had dead batts. and also the motor wires were off.can anyone tell the proper way the wires go.Thanks
treadhead is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
How to check motor on G9E? Electric Yamaha
how do i check my motor for power Electric EZGO
Fastest way to check motor! Electric Yamaha
I am a nerd but check this out. Motor acceleration with gears. Extreme DC!
motor check Electric Club Car


All times are GMT -5. The time now is 02:56 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.