lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 06-01-2018, 06:56 AM   #1
DCHadesty
Not Yet Wild
 
Join Date: May 2018
Posts: 3
Default Yamaha g22 electrical issues

Had my cart in the garage all winter with the charger plugged in. Had it out several times so I could work on a car with no problems. Went to take it to the campground and it was dead.
After looking I found that there was a 3amp fuse that was blown, I replaced the fuse and flipped the run/tow switch and I heard the solenoid click but still would not go. Tried it again last night only to find that the 3amp fuse blew again. Could this possibility be a bad solenoide?
DCHadesty is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 06-01-2018, 11:17 AM   #2
biphase
Gone Wild
 
biphase's Avatar
 
Join Date: Jan 2009
Location: Ocala, FL
Posts: 343
Default Re: Yamaha g22 electrical issues

If you have an Alltrax controller in your cart, you should replace the 3 amp fuse with a 10 amp fuse. Do not increase the fuse if you have the original controller.
biphase is offline   Reply With Quote
Old 06-01-2018, 05:13 PM   #3
DCHadesty
Not Yet Wild
 
Join Date: May 2018
Posts: 3
Default Re: Yamaha g22 electrical issues

Every time I replace the 3amp fuse it keeps blowing when flip the switch from tow to run.
DCHadesty is offline   Reply With Quote
Old 06-01-2018, 08:44 PM   #4
cgtech
Over This Interview Is...
 
cgtech's Avatar
Yamaha
 
Join Date: Jun 2012
Location: AZ
Posts: 17,434
Default Re: Yamaha g22 electrical issues

Unplug the solenoid small wires, the motor speed sensor, the throttle position sensor then try again with new fuse. If it still immedately fries, likely bad controller. If not, plug one thing back in at a time until you find the one that pops the fuse.
cgtech is offline   Reply With Quote
Old 06-02-2018, 01:47 PM   #5
DCHadesty
Not Yet Wild
 
Join Date: May 2018
Posts: 3
Default Re: Yamaha g22 electrical issues

Thanks, will try that when I get home from work.
DCHadesty is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
g9 Electrical Issues Gas Yamaha
electrical issues Gas EZGO
Electrical Issues Gas EZGO
Yamaha G16E Electrical Issues! Electric Yamaha
94 G8 Electrical issues Electric Yamaha


All times are GMT -5. The time now is 09:43 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.