|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-26-2016, 07:17 PM | #1 |
Not Yet Wild
Join Date: Feb 2009
Posts: 33
|
Resistor Control Assembly
What in the world does the resistor control assembly do. Here is the scenario, 2008 RXV. Cart wont do anything so I check all the batteries. Everything is good. Plug my computer in and check error codes. 12576 DC BUS TIMEOUT. Go through diagnostic steps one and two and the check correct. Step three: Remove resistor control module connection to controller B- terminal, if error status changes follow action 1. Action 1: replace resistor control module.
So here is the problem, or solution, THE CART RUNS GREAT with the resistor module disconnected. What does it do and do I need it, (very expensive) WTF - |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-26-2016, 09:24 PM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Resistor Control Assembly
its job is "a place to dispose of extra energy when the batteries are already full". the rxv relies on motor regeneration for electric braking to slow the vehicle. in a rare scenario where you required braking and the batteries were super-totally-full, where is the cart to put the energy created by braking? The Resistor... this rare scenario could occur if you lived on top of a hill, and had just unplugged the charger before leaving. while unlikely, this possibility had to be addressed too.
|
02-20-2018, 11:21 AM | #3 |
Not Yet Wild
Join Date: Feb 2018
Location: Malcolm ,Al.
Posts: 1
|
Re: Resistor Control Assembly
I have a 2009 and we were running down the road and Cart went into total lockdown and we had extreme heat from under the passenger side of seat , any idea?
|
02-20-2018, 12:53 PM | #4 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: Resistor Control Assembly
rockin --- start a new thread please...
|
04-25-2020, 06:03 PM | #5 |
Not Yet Wild
Join Date: Feb 2017
Posts: 2
|
Re: Resistor Control module
I have a 2009 ezgo rxv my question is.
How can you check the resistor control modual and can you run without it?? Last edited by Jim Soby; 04-25-2020 at 06:08 PM.. Reason: Update title |
04-25-2020, 09:49 PM | #6 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Resistor Control Assembly
Download Danaher rxv troubleshooting guide.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Resistor Cart Speed Control Mod | Electric EZGO | |||
Melex 252 resistor speed control electrical problem | Melex | |||
Resistor to Control Cart | Electric EZGO | |||
resistor group assembly | Electric Club Car | |||
Resistor board assembly problems | Electric EZGO |