|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-12-2015, 04:27 PM | #1 |
Getting Wild
Join Date: Oct 2007
Location: Charleston, SC
Posts: 106
|
Battery Diagram
My 2008 RXV runs about 25 yards then slows and stops. Even when its running it is very slow. Wait 5 minutes and it will go again another 25 feet and stop. I suspect my battery charger is not working. Can anyone show a diagram of how to test pack voltage on the cart ? What about test procedure for the charger? All help appreciated. I am a novice at this. Thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-12-2015, 06:07 PM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Battery Diagram
Total pack voltage needs to be above 48v, should be about 50.5 when full. Test charger- plug in to cart & wall, monitor pack voltage at terminals with cables that go away from the other linked batts (neg is far right rear battery, pos is front right battery, forward most terminal). Battery voltage dropping below low 40s during operation will result in cart slowdown due to low voltage. Post results.
|
08-12-2015, 06:22 PM | #3 |
Getting Wild
Join Date: Oct 2007
Location: Charleston, SC
Posts: 106
|
Re: Battery Diagram
Thanks CG. Pack voltage is 51.3 and steady over 1 minute. I'm going to charge it overnight, then try it out tomorrow.
|
08-12-2015, 06:27 PM | #4 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Battery Diagram
Go back to it again in 15 mins, if the charger is still indicating its charging, check the voltage again. It should be reaching 59ish volts when near the end of the charge cycle.
|
08-12-2015, 06:49 PM | #5 |
Getting Wild
Join Date: Oct 2007
Location: Charleston, SC
Posts: 106
|
Re: Battery Diagram
Now 51.7
|
08-13-2015, 08:31 AM | #6 |
Getting Wild
Join Date: Oct 2007
Location: Charleston, SC
Posts: 106
|
Re: Battery Diagram
Checked this morning after charging overnight (approx 12 hrs) and its only 51.3. Havent driven it yet but will later this am.
Thanks |
|
|
Similar Threads | ||||
Thread | Forum | |||
Help--- need battery diagram for medalist | Electric EZGO | |||
1996 ez-go battery diagram | Electric EZGO | |||
Battery Wire Diagram | Gas EZGO | |||
battery diagram | Electric Club Car |