|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-03-2020, 12:52 PM | #1 |
Not Yet Wild
Join Date: May 2020
Posts: 3
|
2016 precedent- Test controller
I have a 2016 club car precedent. All batteries are fully charged and I have replaced the solenoid. The cart continues to jump 1” when pedal is pressed.
Is there a way to check if the controller is bad? Or maybe test the motor it self? Would like some ideas before I just order a new controller and it may not be the problem. Thanks so much. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-03-2020, 04:37 PM | #2 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2016 precedent- Test controller
to BGW
With the rear of the cart up in the air, you can make sure that the controller is getting pack voltage at the B+ and B- posts with the solenoid engaged Your issue may be with your MCOR (throttle device). With the cart off, pump the go pedal roughly 30 times, then try to drive and see if things change. |
05-08-2020, 04:02 PM | #3 |
Not Yet Wild
Join Date: May 2020
Posts: 3
|
Re: 2016 precedent- Test controller
So I jacked the rear wheels in the air and they spin freely when it’s up. Tried the pedal 30 times as well.
Any other suggestions |
05-08-2020, 05:16 PM | #4 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2016 precedent- Test controller
What is your pack voltage, and how old are the batts?
|
05-08-2020, 05:42 PM | #5 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,226
|
Re: 2016 precedent- Test controller
It sounds like it's running through the precharge resistor. Is the solenoid pulling in?
|
05-08-2020, 11:24 PM | #6 |
Not Yet Wild
Join Date: May 2020
Posts: 3
|
Re: 2016 precedent- Test controller
The solenoid is clicking when I engage the pedal. Is there a way to test the resistor? Or is in easier to just replace it?
|
05-09-2020, 12:31 PM | #7 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,226
|
Re: 2016 precedent- Test controller
Does the resistor get hot when it tries to run?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2016 RXV controller swap | Electric EZGO | |||
Controller Wiring 2016 CC Precedent | Electric Club Car | |||
2016 EZGO RXV won’t perform twist test | Electric EZGO | |||
2016 CC motor & controller | Golf Carts and Parts | |||
2016 Precedent | Electric Club Car |