|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-28-2020, 06:41 PM | #1 |
Not Yet Wild
Join Date: May 2020
Location: Florida
Posts: 10
|
01 Club Car DS 48v wont move/new solenoid & controller
So im about to lose my mind, it's been about 3 months my cart stopped working. It started with it stuttering and one day it just stopped raining. I have change the solenoid & controller, I tested the motor & it runs, I tested the forward and reverse micro switches and they're good, I also bypass the OBC, same results. I have attached a picture of the app for the controller, I'm trying to figure out how much is the throttle voltage that it's supposed to have when you press the throttle down because it's giving me 4.99. Thanks in advance for your help!!!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-28-2020, 06:54 PM | #2 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
What is the total voltage of the batteries? The "pack" voltage.
|
05-28-2020, 08:11 PM | #3 |
Not Yet Wild
Join Date: May 2020
Location: Florida
Posts: 10
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
|
05-30-2020, 01:51 PM | #4 | |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
Quote:
Now tell me about your cart. What all have you done to it and what it in it now? |
|
05-30-2020, 01:53 PM | #5 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
And your screen shot does not tell me anything. I need one where you have the key On, Pedal depressed, Fwd selected, and Run/Tow in Run. Then take a screen shot and post it.
Be sure to have it jacked up so it does not run away on you if it were to engage. |
06-02-2020, 10:30 PM | #6 | |
Not Yet Wild
Join Date: May 2020
Location: Florida
Posts: 10
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
Quote:
Things I have changed sofar below. Controler Navitas 10-000766 Red Hawk Solenoid SOL-1022 MCOR Things that I have tested below. Forward and reverse switch appeared to be fine. I jumped started the motor and its working. Im assuming the OBC is working since its charging. Power to the key switch Checked the cables and made sure everything is snug I did an OBC bypass and nothing happened. I look forward to your reply!! Thanks |
|
06-03-2020, 12:08 AM | #7 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
According to your programmer, it is not seeing a direction (Fwd or Rev) selected.
And I want to make sure, this is a Series cart? FNR Lever and not a Fwd/Rev Rocker switch. |
06-03-2020, 08:00 AM | #8 |
Not Yet Wild
Join Date: May 2020
Location: Florida
Posts: 10
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
|
06-03-2020, 08:33 AM | #9 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
If You have a Series cart and are not using the Controller F1 and F2 posts, I think SEM is wrong in the Motor type.
Check Your manual and switch the Controller to Series Motor since it comes configured as Sepex by default from factory. |
06-03-2020, 11:09 AM | #10 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 01 Club Car DS 48v wont move/new solenoid & controller
That's where I am at. SEM was causing me an issue unless it was a Sepex as I was on Series. (And I was not sure what SEM stood for I have always saw SEP or SER for the motor abbreviations)
|
Tags |
club car ds 48v wont move |
|
|
Similar Threads | ||||
Thread | Forum | |||
New Solenoid installed - club car wont move | Electric Club Car | |||
96 Club Car DS 48v wont move/no solenoid click | Electric Club Car | |||
96 club car ds solenoid wont click and cart wont move unless you jump solenoid | Electric Club Car | |||
melex 512e has good solenoid,36 volts to controller, wont move | Melex | |||
Club Car wont move, dead solenoid? | Electric Club Car |