|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-09-2015, 04:32 PM | #1 |
Not Yet Wild
Join Date: Mar 2015
Location: Ne.
Posts: 20
|
83 ezgo gasser rear seal.
My 83 ezgo gasser blew the rear seal out. Where can I get a new seal to replace the old one? Why do you think it blew out, anything other than age? It has back fired a few times. Any tips, or tricks would be appreciated on how to replace the seal. The only way I see feasible is to remove the engine and pull the clutch. Is there a special tool out there to pull the clutch that I will need? It wont start due to loss of compression on bottom side with the seal out but if I push it back in it runs like a champ until it back fires and pushes the rear seal back out.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-09-2015, 05:32 PM | #2 |
Gone Wild
Join Date: Mar 2015
Location: Central mn
Posts: 1,036
|
Re: 83 ezgo gasser rear seal.
Clean out the seal with clutch in place.
Try to clean crank Put locktite on the seal and try some tools to push it into place I've done this before and it worked Sure beats pulling the clutch! |
12-09-2015, 06:06 PM | #3 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,491
|
Re: 83 ezgo gasser rear seal.
The back firing is blowing out your seal. It's caused by the throttle cable not being properly rigged. Go to post #5 of this thread. http://www.buggiesgonewild.com/gas-e...t-go-slow.html
The pictures show how it is supposed to look, and where the spring goes. |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
WTB : EZGO rear end with f n r for a gasser | Golf Carts and Parts | |||
WTB : EZGO Rear End for Gasser | Golf Carts and Parts | |||
84 EZGO Rear End Seal?? | Gas EZGO | |||
1985 EZGO Marathon Rear End Seal | Gas EZGO | |||
WTB: EZGO Gasser Rear End | Golf Carts and Parts |